Mazda6 WIRING DIAGRAM and Workshop MANUAL

Mazda6 Workshop MANUAL

WORKSHOP MANUAL

GENERAL INFORMATION ENGINE SUSPENSION DRIVELINE/AXLE Brakes TRANSMISSION/TRANSAXLE STEERING HVAC RESTRAINTS Body and Accessories

Workshop MANUAL-GENERAL INFORMATION

GENERAL INFORMATION

VEHICLE IDENTIFICATION NUMBER (VI N) CODE VEHICLE IDENTIFICATION NUMBER (VI N) HOW TO USE THIS MANUAL UNI TS SERVICE CAUTIONS INSTALLATION OF RADIO SYSTEM ELECTRI CAL SYSTEM JACKING POSITIONS, VEHICLE LIFT (2 SUPPORTS) AND SAFETY STAND (RIGID RACK) POSITIONS TOW I NG IDENTIFICATION NUMBER LOCATI ONS SAE STANDARDS ABBREVI ATI ONS PRE-DELI VERY INSPECTION SCHEDULED MAINTENANCE

Workshop MANUAL-ENGINE

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [MZR 2.5] MONITORING SYSTEM AND CONTROL SYSTEM DEVICE RELATIONSHIP CHART [MZR 2.5] OBD-I I PENDI NG TROUBLE CODE [MZR 2.5] OBD-I I FREEZE FRAME DATA [MZR 2.5] OBD-I I ON-BOARD SYSTEM READI NESS TEST [MZR 2.5] OBD-I I READ/CLEAR DIAGNOSTIC TEST RESULTS [MZR 2.5] OBD-I I PARAMETER IDENTIFICATION (PID) ACCESS [MZR 2.5] ON-BOARD DIAGNOSTIC TEST [MZR 2.5] AFTER REPAIR PROCEDURE [MZR 2.5] KOEO/KOER SELF TEST [MZR 2.5] OBD-I I DRIVE MODE [MZR 2.5] DIAGNOSTIC MONITORING TEST RESULTS [MZR 2.5] DTC TABLE [MZR 2.5] DTC P0 01 1: 00 [MZR 2.5] DTC P0 01 2: 00 [MZR 2.5] DTC P0 01 6: 00 [MZR 2.5] DTC P0 03 0: 00 [MZR 2.5] DTC P0 03 1: 00 [MZR 2.5] DTC P0 03 2: 00 [MZR 2.5] DTC P0 03 7: 00 [MZR 2.5] DTC P0 03 8: 00 [MZR 2.5] DTC P0 05 3: 00 [MZR 2.5] DTC P0 05 4: 00 [MZR 2.5] DTC P0 06 9: 00 [MZR 2.5] DTC P0 10 1: 00 [MZR 2.5] DTC P0 10 2: 00 [MZR 2.5] DTC P0 10 3: 00 [MZR 2.5] DTC P0 10 7: 00 [MZR 2.5] DTC P0 10 8: 00 [MZR 2.5] DTC P0 11 1: 00 [MZR 2.5] DTC P0 11 2: 00 [MZR 2.5] DTC P0 11 3: 00 [MZR 2.5] DTC P0 11 6: 00 [MZR 2.5] DTC P0 11 7: 00 [MZR 2.5] DTC P0 11 8: 00 [MZR 2.5] DTC P0 12 2: 00 [MZR 2.5] DTC P0 12 3: 00 [MZR 2.5] DTC P0 12 5: 00 [MZR 2.5] DTC P0 12 6: 00 , P0 12 8: 00 [MZR 2.5] DTC P0 13 0: 00 [MZR 2.5] DTC P0 13 1: 00 [MZR 2.5] DTC P0 13 2: 00 [MZR 2.5] DTC P0 13 3: 00 [MZR 2.5] DTC P0 13 4: 00 [MZR 2.5] DTC P0 13 7: 00 [MZR 2.5] DTC P0 13 8: 00 [MZR 2.5] DTC P0 13 9: 00 [MZR 2.5] DTC P0 14 0: 00 [MZR 2.5] DTC P0 17 1: 00 [MZR 2.5] DTC P0 17 2: 00 [MZR 2.5] DTC P0 22 2: 00 [MZR 2.5] DTC P0 22 3: 00 [MZR 2.5] DTC P0 30 0: 00 [MZR 2.5] DTC P0 30 1: 00 , P0 30 2: 00 , P0 30 3: 00 , P0 30 4: 00 [MZR 2.5] DTC P0 32 7: 00 [MZR 2.5] DTC P0 32 8: 00 [MZR 2.5] DTC P0 33 5: 00 [MZR 2.5] DTC P0 34 0: 00 [MZR 2.5] DTC P0 40 1: 00 [MZR 2.5] DTC P0 40 3: 00 [MZR 2.5] DTC P0 42 1: 00 [MZR 2.5] DTC P0 44 2: 00 , P0 45 5: 00 , P0 45 6: 00 [MZR 2.5] DTC P0 44 3: 00 [MZR 2.5] DTC P0 44 6: 00 [MZR 2.5] DTC P0 45 1: 00 [MZR 2.5] DTC P0 45 2: 00 [MZR 2.5] DTC P0 45 3: 00 [MZR 2.5] DTC P0 45 4: 00 [MZR 2.5] DTC P0 45 7: 00 [MZR 2.5] DTC P0 46 0: 00 [MZR 2.5] DTC P0 46 1: 00 [MZR 2.5] DTC P0 46 2: 00 [MZR 2.5] DTC P0 46 3: 00 [MZR 2.5] DTC P0 48 0: 00 [MZR 2.5] DTC P0 50 0: 00 [MZR 2.5] DTC P0 50 5: 00 [MZR 2.5] DTC P0 50 6: 00 [MZR 2.5] DTC P0 50 7: 00 [MZR 2.5] DTC P0 50 A: 00 [MZR 2.5] DTC P0 50 B: 00 [MZR 2.5] DTC P0 55 0: 00 [MZR 2.5] DTC P0 57 1: 00 [MZR 2.5] DTC P0 57 9: 00 [MZR 2.5] DTC P0 58 1: 00 [MZR 2.5] DTC P0 60 0: 00 [MZR 2.5] DTC P0 60 1: 00 [MZR 2.5] DTC P0 60 2: 00 [MZR 2.5] DTC P0 60 4: 00 [MZR 2.5] DTC P0 60 6: 00 [MZR 2.5] DTC P0 60 7: 00 [MZR 2.5] DTC P0 60 A: 00 , P0 60 C: 00 , P0 61 D: 00 [MZR 2.5] DTC P0 60 B: 00 [MZR 2.5] DTC P0 61 0: 00 [MZR 2.5] DTC P0 61 B: 00 [MZR 2.5] DTC P0 61 F: 00 [MZR 2.5] DTC P0 63 8: 00 [MZR 2.5] DTC P0 64 D: 00 [MZR 2.5] DTC P0 66 1: 00 [MZR 2.5] DTC P0 66 2: 00 [MZR 2.5] DTC P0 68 5: 00 [MZR 2.5] DTC P0 6 B8: 00 [MZR 2.5] DTC P0 70 3: 00 [MZR 2.5] DTC P0 70 4: 00 [MZR 2.5] DTC P0 85 0: 00 [MZR 2.5] DTC P1 26 0: 00 [MZR 2.5] DTC P1 44 A: 00 [MZR 2.5] DTC P1 45 0: 00 [MZR 2.5] DTC P1 67 4: 00 [MZR 2.5] DTC P2 08 8: 00 [MZR 2.5] DTC P2 08 9: 00 [MZR 2.5] DTC P2 09 6: 00 [MZR 2.5] DTC P2 00 4: 00 [MZR 2.5] DTC P2 00 6: 00 [MZR 2.5] DTC P2 00 9: 00 [MZR 2.5] DTC P2 01 0: 00 [MZR 2.5] DTC P2 01 6: 00 [MZR 2.5] DTC P2 01 7: 00 [MZR 2.5] DTC P2 09 7: 00 [MZR 2.5] DTC P2 10 0: 00 [MZR 2.5] DTC P2 10 1: 00 [MZR 2.5] DTC P2 10 5: 00 [MZR 2.5] DTC P2 10 7: 00 [MZR 2.5] DTC P2 10 8: 00 [MZR 2.5] DTC P2 11 0: 00 [MZR 2.5] DTC P2 11 9: 00 [MZR 2.5] DTC P2 12 2: 00 [MZR 2.5] DTC P2 12 3: 00 [MZR 2.5] DTC P2 12 7: 00 [MZR 2.5] DTC P2 12 8: 00 [MZR 2.5] DTC P2 13 5: 00 [MZR 2.5] DTC P2 13 8: 00 [MZR 2.5] DTC P2 22 8: 00 [MZR 2.5] DTC P2 22 9: 00 [MZR 2.5] DTC P2 23 7: 00 [MZR 2.5] DTC P2 24 3: 00 [MZR 2.5] DTC P2 25 1: 00 [MZR 2.5] DTC P2 29 9: 00 [MZR 2.5] DTC P2 50 2: 00 [MZR 2.5] DTC P2 50 3: 00 [MZR 2.5] DTC P2 50 4: 00 [MZR 2.5] DTC P2 50 7: 00 [MZR 2.5] DTC P2 60 F: 00 [MZR 2.5] DTC P2 61 0: 00 [MZR 2.5] DTC U3 00 0: 41 [MZR 2.5]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [MZI 3.7 V6] FOREWORD [MZI 3.7 V6] ON-BOARD DIAGNOSTIC TEST [MZI 3.7 V6] AFTER REPAIR PROCEDURE [MZI 3.7 V6] KOEO/KOER SELF TEST [MZI 3.7 V6] OBD-I I DRIVE MODE [MZI 3.7 V6] DIAGNOSTIC MONITORING TEST RESULTS [MZI 3.7 V6] DTC TABLE [MZI 3.7 V6] DTC P0 01 0: 00 [MZI 3.7 V6] DTC P0 01 1: 00 [MZI 3.7 V6] DTC P0 01 2: 00 [MZI 3.7 V6] DTC P0 01 6: 00 , P0 01 8: 00 [MZI 3.7 V6] DTC P0 02 0: 00 [MZI 3.7 V6] DTC P0 02 1: 00 [MZI 3.7 V6] DTC P0 02 2: 00 [MZI 3.7 V6] DTC P0 03 0: 00 , P0 05 0: 00 [MZI 3.7 V6] DTC P0 04 0: 00 , P0 04 1: 00 [MZI 3.7 V6] DTC P0 05 3: 00 , P0 05 9: 00 [MZI 3.7 V6] DTC P0 05 4: 00 , P0 06 0: 00 [MZI 3.7 V6] DTC P0 06 8: 00 [MZI 3.7 V6] DTC P0 10 2: 00 [MZI 3.7 V6] DTC P0 10 3: 00 [MZI 3.7 V6] DTC P0 10 4: 00 [MZI 3.7 V6] DTC P0 11 1: 00 [MZI 3.7 V6] DTC P0 11 2: 00 [MZI 3.7 V6] DTC P0 11 3: 00 [MZI 3.7 V6] DTC P0 11 4: 00 [MZI 3.7 V6] DTC P0 11 6: 00 [MZI 3.7 V6] DTC P0 12 2: 00 [MZI 3.7 V6] DTC P0 12 3: 00 [MZI 3.7 V6] DTC P0 12 8: 00 [MZI 3.7 V6] DTC P0 13 1: 00 , P0 15 1: 00 [MZI 3.7 V6] DTC P0 13 2: 00 , P0 15 2: 00 [MZI 3.7 V6] DTC P0 13 3: 00 , P0 15 3: 00 [MZI 3.7 V6] DTC P0 13 5: 00 , P0 15 5: 00 [MZI 3.7 V6] DTC P0 13 7: 00 , P0 15 7: 00 [MZI 3.7 V6] DTC P0 13 8: 00 , P0 15 8: 00 [MZI 3.7 V6] DTC P0 13 A: 00 [MZI 3.7 V6] DTC P0 13 C: 00 [MZI 3.7 V6] DTC P0 13 E: 00 [MZI 3.7 V6] DTC P0 14 1: 00 , P0 16 1: 00 [MZI 3.7 V6] DTC P0 14 8: 00 [MZI 3.7 V6] DTC P0 14 A: 00 [MZI 3.7 V6] DTC P0 17 1: 00 , P0 17 4: 00 [MZI 3.7 V6] DTC P0 17 2: 00 , P0 17 5: 00 [MZI 3.7 V6] DTC P0 20 1: 00 [MZI 3.7 V6] DTC P0 20 2: 00 [MZI 3.7 V6] DTC P0 20 3: 00 [MZI 3.7 V6] DTC P0 20 4: 00 [MZI 3.7 V6] DTC P0 20 5: 00 [MZI 3.7 V6] DTC P0 20 6: 00 [MZI 3.7 V6] DTC P0 21 7: 00 [MZI 3.7 V6] DTC P0 21 9: 00 [MZI 3.7 V6] DTC P0 22 2: 00 [MZI 3.7 V6] DTC P0 22 3: 00 [MZI 3.7 V6] DTC P0 23 0: 00 [MZI 3.7 V6] DTC P0 23 1: 00 [MZI 3.7 V6] DTC P0 23 2: 00 [MZI 3.7 V6] DTC P0 29 7: 00 [MZI 3.7 V6] DTC P0 30 0: 00 [MZI 3.7 V6] DTC P0 30 1: 00 , P0 30 2: 00 , P0 30 3: 00 , P0 30 4: 00 , P0 30 5: 00 , P0 30 6: 00 , P0 31 6: 00 [MZI 3.7 V6] DTC P0 31 5: 00 [MZI 3.7 V6] DTC P0 32 0: 00 [MZI 3.7 V6] DTC P0 32 5: 00 [MZI 3.7 V6] DTC P0 33 0: 00 [MZI 3.7 V6] DTC P0 34 0: 00 [MZI 3.7 V6] DTC P0 34 1: 00 [MZI 3.7 V6] DTC P0 34 4: 00 [MZI 3.7 V6] DTC P0 34 5: 00 [MZI 3.7 V6] DTC P0 34 6: 00 [MZI 3.7 V6] DTC P0 34 9: 00 [MZI 3.7 V6] DTC P0 35 1: 00 , P0 35 2: 00 , P0 35 3: 00 , P0 35 4: 00 , P0 35 5: 00 , P0 35 6: 00 [MZI 3.7 V6] DTC P0 42 0: 00 , P0 43 0: 00 [MZI 3.7 V6] DTC P0 44 2: 00 , P0 45 5: 00 , P0 45 6: 00 [MZI 3.7 V6] DTC P0 44 3: 00 [MZI 3.7 V6] DTC P0 44 6: 00 [MZI 3.7 V6] DTC P0 45 1: 00 [MZI 3.7 V6] DTC P0 45 2: 00 [MZI 3.7 V6] DTC P0 45 3: 00 [MZI 3.7 V6] DTC P0 45 4: 00 [MZI 3.7 V6] DTC P0 45 7: 00 [MZI 3.7 V6] DTC P0 46 0: 00 [MZI 3.7 V6] DTC P0 46 1: 00 [MZI 3.7 V6] DTC P0 46 2: 00 [MZI 3.7 V6] DTC P0 46 3: 00 [MZI 3.7 V6] DTC P0 48 0: 00 [MZI 3.7 V6] DTC P0 50 4: 00 [MZI 3.7 V6] DTC P0 50 5: 00 [MZI 3.7 V6] DTC P0 50 6: 00 [MZI 3.7 V6] DTC P0 50 7: 00 [MZI 3.7 V6] DTC P0 50 A: 00 [MZI 3.7 V6] DTC P0 50 B: 00 [MZI 3.7 V6] DTC P0 50 E: 00 [MZI 3.7 V6] DTC P0 53 2: 00 [MZI 3.7 V6] DTC P0 53 3: 00 [MZI 3.7 V6] DTC P0 56 2: 00 [MZI 3.7 V6] DTC P0 56 3: 00 [MZI 3.7 V6] DTC P0 57 2: 00 [MZI 3.7 V6] DTC P0 57 3: 00 [MZI 3.7 V6] DTC P0 57 9: 00 [MZI 3.7 V6] DTC P0 58 1: 00 [MZI 3.7 V6] DTC P0 60 0: 00 [MZI 3.7 V6] DTC P0 60 2: 00 [MZI 3.7 V6] DTC P0 60 3: 00 [MZI 3.7 V6] DTC P0 60 4: 00 [MZI 3.7 V6] DTC P0 60 5: 00 [MZI 3.7 V6] DTC P0 60 7: 00 [MZI 3.7 V6] DTC P0 60 A: 00 , P0 60 C: 00 , P0 61 D: 00 [MZI 3.7 V6] DTC P0 60 B: 00 [MZI 3.7 V6] DTC P0 61 0: 00 [MZI 3.7 V6] DTC P0 61 A: 00 [MZI 3.7 V6] DTC P0 61 B: 00 [MZI 3.7 V6] DTC P0 61 C: 00 [MZI 3.7 V6] DTC P0 62 0: 00 [MZI 3.7 V6] DTC P0 62 5: 00 [MZI 3.7 V6] DTC P0 62 6: 00 [MZI 3.7 V6] DTC P0 62 F: 00 [MZI 3.7 V6] DTC P0 64 2: 00 [MZI 3.7 V6] DTC P0 64 3: 00 [MZI 3.7 V6] DTC P0 64 5: 00 [MZI 3.7 V6] DTC P0 64 D: 00 , P0 64 E: 00 [MZI 3.7 V6] DTC P0 65 B: 00 [MZI 3.7 V6] DTC P0 68 5: 00 [MZI 3.7 V6] DTC P0 68 A: 00 [MZI 3.7 V6] DTC P0 6 B8: 00 [MZI 3.7 V6] DTC P1 00 1: 00 [MZI 3.7 V6] DTC P1 10 1: 00 [MZI 3.7 V6] DTC P1 12 4: 00 [MZI 3.7 V6] DTC P1 12 7: 00 [MZI 3.7 V6] DTC P1 15 E: 00 [MZI 3.7 V6] DTC P1 26 0: 00 [MZI 3.7 V6] DTC P1 28 5: 00 , P1 29 9: 00 [MZI 3.7 V6] DTC P1 28 8: 00 [MZI 3.7 V6] DTC P1 28 9: 00 [MZI 3.7 V6] DTC P1 28 A: 00 [MZI 3.7 V6] DTC P1 29 0: 00 [MZI 3.7 V6] DTC P1 33 6: 00 [MZI 3.7 V6] DTC P1 39 7: 00 [MZI 3.7 V6] DTC P1 44 A: 00 [MZI 3.7 V6] DTC P1 45 0: 00 [MZI 3.7 V6] DTC P1 46 4: 00 [MZI 3.7 V6] DTC P1 50 1: 00 [MZI 3.7 V6] DTC P1 57 5: 00 [MZI 3.7 V6] DTC P1 63 3: 00 [MZI 3.7 V6] DTC P1 63 5: 00 [MZI 3.7 V6] DTC P1 63 9: 00 [MZI 3.7 V6] DTC P1 64 6: 00 , P1 64 7: 00 [MZI 3.7 V6] DTC P1 64 A: 00 [MZI 3.7 V6] DTC P1 64 B: 00 [MZI 3.7 V6] DTC P1 65 0: 00 [MZI 3.7 V6] DTC P1 67 4: 00 [MZI 3.7 V6] DTC P1 70 3: 00 [MZI 3.7 V6] DTC P1 70 5: 00 [MZI 3.7 V6] DTC P2 09 6: 00 , P2 09 8: 00 [MZI 3.7 V6] DTC P2 09 7: 00 , P2 09 9: 00 [MZI 3.7 V6] DTC P2 10 1: 00 [MZI 3.7 V6] DTC P2 10 7: 00 [MZI 3.7 V6] DTC P2 11 1: 00 [MZI 3.7 V6] DTC P2 11 2: 00 [MZI 3.7 V6] DTC P2 12 2: 00 [MZI 3.7 V6] DTC P2 12 3: 00 [MZI 3.7 V6] DTC P2 12 7: 00 [MZI 3.7 V6] DTC P2 12 8: 00 [MZI 3.7 V6] DTC P2 13 5: 00 [MZI 3.7 V6] DTC P2 13 8: 00 [MZI 3.7 V6] DTC P2 19 5: 00 , P2 19 7: 00 [MZI 3.7 V6] DTC P2 19 6: 00 , P2 19 8: 00 [MZI 3.7 V6] DTC P2 19 A: 00 , P2 19 B: 00 [MZI 3.7 V6] DTC P2 23 7: 00 , P2 24 0: 00 [MZI 3.7 V6] DTC P2 24 3: 00 , P2 24 7: 00 [MZI 3.7 V6] DTC P2 25 1: 00 , P2 25 4: 00 [MZI 3.7 V6] DTC P2 27 0: 00 , P2 27 2: 00 [MZI 3.7 V6] DTC P2 27 1: 00 , P2 27 3: 00 [MZI 3.7 V6] DTC P2 29 9: 00 [MZI 3.7 V6] DTC P2 60 F: 00 [MZI 3.7 V6] DTC P2 61 0: 00 [MZI 3.7 V6] DTC P2 62 7: 00 [MZI 3.7 V6] DTC P2 63 0: 00 [MZI 3.7 V6] DTC U0 30 0: 00 , U0 30 0: 01 , U0 30 0: 02 [MZI 3.7 V6] DTC P2 A0 1: 00 , P2 A0 4: 00 [MZI 3.7 V6]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING WIRING DIAGRAM [MZR 2.5] FOREWORD [MZR 2.5] SYMPTOM DIAGNOSTIC INDEX [MZR 2.5] CONTROL SYSTEM DEVICE AND CONTROL RELATIONSHIP CHART [MZR 2.5] QUICK DIAGNOSTIC CHART [MZR 2.5] NO.1 MELTING OF MAIN OR OTHER FUSES [MZR 2.5] NO.2 MIL ILLUMINATES [MZR 2.5] NO.3 WILL NOT CRANK [MZR 2.5] NO.4 HARD TO START/LONG CRANK/ERRATIC START/ERRATIC CRANK [MZR 2.5] NO.5 ENGINE STALLS-AFTER START/AT IDLE [MZR 2.5] NO.6 CRANKS NORMALLY BUT WILL NOT START [MZR 2.5] NO.7 SLOW RETURN TO IDLE [MZR 2.5] NO.8 ENGINE RUNS ROUGH/ROLLI NG IDLE [MZR 2.5] NO.9 FAST IDLE/RUNS ON [MZR 2.5] NO.10 LOW IDLE/STALLS DURI NG DECELERATION [MZR 2.5] NO.11 ENGINE STALLS/QUI TS, ENGINE RUNS ROUGH, MI SSES, BUCK/JERK, HESI TATI ON/STUMBLE, SURGES [MZR 2.5] NO.12 LACK/LOSS OF POWER-ACCELERATION/CRUI SE [MZR 2.5] NO.13 KNOCKING/PINGING-ACCELERATION/CRUI SE [MZR 2.5] NO.14 POOR FUEL ECONOMY [MZR 2.5] NO.15 EMISSION COMPLIANCE [MZR 2.5] NO.16 HIGH OIL CONSUMPTION/LEAKAGE [MZR 2.5] NO.17 COOLING SYSTEM CONCERNS-OVERHEATING [MZR 2.5] NO.18 COOLING SYSTEM CONCERNS-RUNS COLD [MZR 2.5] NO.19 EXHAUST SMOKE [MZR 2.5] NO.20 FUEL ODOR (IN ENGINE COMPARTMENT) [MZR 2.5] NO.21 ENGINE NOISE [MZR 2.5] NO.22 VIBRATION CONCERNS (ENGINE) [MZR 2.5] NO.23 A/C DOES NOT WORK SUFFICIENTLY [MZR 2.5] NO.24 A/C IS ALWAYS ON OR A/C COMPRESSOR RUNS CONTINUOUSLY [MZR 2.5] NO.25 A/C IS NOT CUT OFF UNDER WIDE OPEN THROTTLE CONDITIONS [MZR 2.5] NO.26 EXHAUST SULPHUR SMELL [MZR 2.5] NO.27 FUEL REFI LL CONCERNS [MZR 2.5] NO.28 FUEL FI LLI NG SHUT OFF CONCERNS [MZR 2.5] NO.29 SPARK PLUG CONDI TI ON [MZR 2.5] INTERMITTENT CONCERN TROUBLESHOOTING [MZR 2.5] ENGINE CONTROL SYSTEM OPERATION INSPECTION [MZR 2.5]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING WIRING DIAGRAM [MZI 3.7 V6] FOREWORD [MZI 3.7 V6] SYMPTOM DIAGNOSTIC INDEX [MZI 3.7 V6] QUICK DIAGNOSTIC CHART [MZI 3.7 V6] NO.1 MELTING OF MAIN OR OTHER FUSES [MZI 3.7 V6] NO.2 MIL ILLUMINATES [MZI 3.7 V6] NO.3 WILL NOT CRANK [MZI 3.7 V6] NO.4 HARD TO START/LONG CRANK/ERRATIC START/ERRATIC CRANK [MZI 3.7 V6] NO.5 ENGINE STALLS-AFTER START/AT IDLE [MZI 3.7 V6] NO.6 CRANKS NORMALLY BUT WILL NOT START [MZI 3.7 V6] NO.7 SLOW RETURN TO IDLE [MZI 3.7 V6] NO.8 ENGINE RUNS ROUGH/ROLLI NG IDLE [MZI 3.7 V6] NO.9 FAST IDLE/RUNS ON [MZI 3.7 V6] NO.10 LOW IDLE/STALLS DURI NG DECELERATION [MZI 3.7 V6] NO.11 ENGINE STALLS/QUI TS, ENGINE RUNS ROUGH, MI SSES, BUCK/JERK, HESI TATI ON/STUMBLE, SURGES [MZI 3.7 V6] NO.12 LACK/LOSS OF POWER-ACCELERATION/CRUI SE [MZI 3.7 V6] NO.13 KNOCKING/PINGING-ACCELERATION/CRUI SE [MZI 3.7 V6] NO.14 POOR FUEL ECONOMY [MZI 3.7 V6] NO.15 EMISSION COMPLIANCE [MZI 3.7 V6] NO.16 HIGH OIL CONSUMPTION/LEAKAGE [MZI 3.7 V6] NO.17 COOLING SYSTEM CONCERNS-OVERHEATING [MZI 3.7 V6] NO.18 COOLING SYSTEM CONCERNS-RUNS COLD [MZI 3.7 V6] NO.19 EXHAUST SMOKE [MZI 3.7 V6] NO.20 FUEL ODOR (IN ENGINE COMPARTMENT) [MZI 3.7 V6] NO.21 ENGINE NOISE [MZI 3.7 V6] NO.22 VIBRATION CONCERNS (ENGINE) [MZI 3.7 V6] NO.23 A/C DOES NOT WORK SUFFICIENTLY [MZI 3.7 V6] NO.24 A/C IS ALWAYS ON OR A/C COMPRESSOR RUNS CONTINUOUSLY [MZI 3.7 V6] NO.25 A/C DOES NOT CUT OFF UNDER WIDE OPEN THROTTLE CONDITIONS [MZI 3.7 V6] NO.26 EXHAUST SULPHUR SMELL [MZI 3.7 V6] NO.27 FUEL REFI LL CONCERNS [MZI 3.7 V6] NO.28 FUEL FI LLI NG SHUT OFF CONCERNS [MZI 3.7 V6] NO.29 SPARK PLUG CONDI TI ON [MZI 3.7 V6] INTERMITTENT CONCERN TROUBLESHOOTING [MZI 3.7 V6] ENGINE CONTROL SYSTEM OPERATION INSPECTION [MZI 3.7 V6]

MECHANICAL

ENGINE LOCATION INDEX [MZR 2.5] ENGINE TUNE-UP [MZR 2.5] PLUG HOLE PLATE REMOVAL/INSTALLATION [MZR 2.5] DRIVE BELT INSPECTION [MZR 2.5] DRIVE BELT REMOVAL/INSTALLATION [MZR 2.5] DRIVE BELT AUTO TENSIONER INSPECTION [MZR 2.5] VALVE CLEARANCE INSPECTION [MZR 2.5] VALVE CLEARANCE ADJUSTMENT [MZR 2.5] COMPRESSI ON INSPECTION [MZR 2.5] VARIABLE VALVE TIMING ACTUATOR INSPECTION [MZR 2.5] VARIABLE VALVE TIMING ACTUATOR REMOVAL/INSTALLATION [MZR 2.5] OIL CONTROL VALVE (OCV) INSPECTION [MZR 2.5] OIL CONTROL VALVE (OCV) REMOVAL/INSTALLATION [MZR 2.5] TIMING CHAIN REMOVAL/INSTALLATION [MZR 2.5] CYLINDER HEAD GASKET REPLACEMENT [MZR 2.5] FRONT OIL SEAL REPLACEMENT [MZR 2.5] REAR OIL SEAL REPLACEMENT [MZR 2.5] ENGINE REMOVAL/INSTALLATION [MZR 2.5] ENGINE DISASSEMBLY/ASSEMBLY [MZR 2.5]

MECHANICAL

ENGINE LOCATION INDEX [MZI 3.7 V6] ENGINE TUNE-UP [MZI 3.7 V6] ENGINE COVER REMOVAL/INSTALLATION [MZI 3.7 V6] DRIVE BELT INSPECTION [MZI 3.7 V6] DRIVE BELT REMOVAL/INSTALLATION [MZI 3.7 V6] DRIVE BELT AUTO TENSIONER INSPECTION [MZI 3.7 V6] VALVE CLEARANCE INSPECTION/ADJUSTMENT [MZI 3.7 V6] COMPRESSI ON INSPECTION [MZI 3.7 V6] VARIABLE VALVE TIMING ACTUATOR REMOVAL/INSTALLATION [MZI 3.7 V6] OIL CONTROL VALVE (OCV) INSPECTION [MZI 3.7 V6] OIL CONTROL VALVE (OCV) REMOVAL/INSTALLATION [MZI 3.7 V6] TIMING CHAIN REMOVAL/INSTALLATION [MZI 3.7 V6] CYLINDER HEAD GASKET REPLACEMENT [MZI 3.7 V6] FRONT OIL SEAL REPLACEMENT [MZI 3.7 V6] REAR OIL SEAL REPLACEMENT [MZI 3.7 V6] ENGINE REMOVAL/INSTALLATION [MZI 3.7 V6] ENGINE DISASSEMBLY/ASSEMBLY [MZI 3.7 V6]

LUBRICATION

LUBRICATION SYSTEM LOCATION INDEX [MZR 2.5] ENGINE OIL LEVEL INSPECTION [MZR 2.5] ENGINE OIL REPLACEMENT [MZR 2.5] OIL FILTER REPLACEMENT [MZR 2.5] OIL PRESSURE INSPECTION [MZR 2.5] OIL COOLER REMOVAL/INSTALLATION [MZR 2.5] OIL PAN REMOVAL/INSTALLATION [MZR 2.5] OIL PUMP REMOVAL/INSTALLATION [MZR 2.5]

LUBRICATION

LUBRICATION SYSTEM LOCATION INDEX [MZI 3.7 V6] ENGINE OIL LEVEL INSPECTION [MZI 3.7 V6] ENGINE OIL REPLACEMENT [MZI 3.7 V6] OIL FILTER REPLACEMENT [MZI 3.7 V6] OIL PRESSURE INSPECTION [MZI 3.7 V6] OIL PAN REMOVAL/INSTALLATION [MZI 3.7 V6] OIL PUMP REMOVAL/INSTALLATION [MZI 3.7 V6]

COOLING SYSTEM

COOLING SYSTEM LOCATION INDEX [MZR 2.5] COOLING SYSTEM SERVICE WARNINGS [MZR 2.5] ENGINE COOLANT LEVEL INSPECTION [MZR 2.5] ENGINE COOLANT REPLACEMENT [MZR 2.5] ENGINE COOLANT PROTECTI ON INSPECTION [MZR 2.5] ENGINE COOLANT LEAKAGE INSPECTION [MZR 2.5] COOLING SYSTEM CAP INSPECTION [MZR 2.5] COOLANT RESERVE TANK REMOVAL/INSTALLATION [MZR 2.5] RADIATOR REMOVAL/INSTALLATION [MZR 2.5] THERMOSTAT REMOVAL/INSTALLATION [MZR 2.5] THERMOSTAT INSPECTION [MZR 2.5] WATER PUMP REMOVAL/INSTALLATION [MZR 2.5] COOLING FAN MOTOR REMOVAL/INSTALLATION [MZR 2.5] COOLING FAN MOTOR INSPECTION [MZR 2.5] FAN CONTROL MODULE INSPECTION [MZR 2.5]

COOLING SYSTEM

COOLING SYSTEM LOCATION INDEX [MZI 3.7 V6] COOLING SYSTEM SERVICE WARNINGS [MZI 3.7 V6] ENGINE COOLANT LEVEL INSPECTION [MZI 3.7 V6] ENGINE COOLANT REPLACEMENT [MZI 3.7 V6] ENGINE COOLANT PROTECTI ON INSPECTION [MZI 3.7 V6] ENGINE COOLANT LEAKAGE INSPECTION [MZI 3.7 V6] COOLING SYSTEM CAP INSPECTION [MZI 3.7 V6] COOLANT RESERVE TANK REMOVAL/INSTALLATION [MZI 3.7 V6] RADIATOR REMOVAL/INSTALLATION [MZI 3.7 V6] THERMOSTAT REMOVAL/INSTALLATION [MZI 3.7 V6] THERMOSTAT INSPECTION [MZI 3.7 V6] WATER PUMP REMOVAL/INSTALLATION [MZI 3.7 V6] COOLING FAN MOTOR REMOVAL/INSTALLATION [MZI 3.7 V6] COOLING FAN MOTOR INSPECTION [MZI 3.7 V6] FAN CONTROL MODULE INSPECTION [MZI 3.7 V6]

IN-TAKE AIR SYSTEM

INTAKE-AIR SYSTEM LOCATION INDEX [MZR 2.5] INTAKE-AIR SYSTEM VACUUM HOSE ROUTI NG DIAGRAM [MZR 2.5] INTAKE-AIR SYSTEM DIAGRAM [MZR 2.5] INTAKE MANIFOLD VACUUM INSPECTION [MZR 2.5] INTAKE-AIR SYSTEM REMOVAL/INSTALLATION [MZR 2.5] AIR CLEANER ELEMENT INSPECTION [MZR 2.5] THROTTLE BODY INSPECTION [MZR 2.5] VARIABLE INTAKE AIR SOLENOID VALVE INSPECTION [MZR 2.5] VARIABLE TUMBLE SOLENOID VALVE INSPECTION [MZR 2.5] VARIABLE INTAKE AIR SHUTTER VALVE ACTUATOR INSPECTION [MZR 2.5] VARIABLE TUMBLE SHUTTER VALVE ACTUATOR INSPECTION [MZR 2.5] ACCELERATOR PEDAL REMOVAL/INSTALLATION [MZR 2.5]

IN-TAKE AIR SYSTEM

INTAKE-AIR SYSTEM LOCATION INDEX [MZI 3.7 V6] INTAKE-AIR SYSTEM VACUUM HOSE ROUTI NG DIAGRAM [MZI 3.7 V6] INTAKE-AIR SYSTEM DIAGRAM [MZI 3.7 V6] INTAKE MANIFOLD VACUUM INSPECTION [MZI 3.7 V6] INTAKE-AIR SYSTEM REMOVAL/INSTALLATION [MZI 3.7 V6] AIR CLEANER ELEMENT INSPECTION [MZI 3.7 V6] THROTTLE BODY INSPECTION [MZI 3.7 V6] ACCELERATOR PEDAL REMOVAL/INSTALLATION [MZI 3.7 V6]

FUEL SYSTEM

FUEL SYSTEM LOCATION INDEX [MZR 2.5] FUEL SYSTEM FLOW DIAGRAM [MZR 2.5] BEFORE SERVICE PRECAUTION [MZR 2.5] AFTER SERVICE PRECAUTION [MZR 2.5] FUEL LINE PRESSURE INSPECTION [MZR 2.5] FUEL TANK REMOVAL/INSTALLATION [MZR 2.5] FUEL TANK INSPECTION [MZR 2.5] NON-RETURN VALVE INSPECTION [MZR 2.5] FUEL PUMP UNIT REMOVAL/INSTALLATION [MZR 2.5] FUEL PUMP UNIT DISASSEMBLY/ASSEMBLY [MZR 2.5] FUEL PUMP UNIT INSPECTION [MZR 2.5] QUICK RELEASE CONNECTOR REMOVAL/INSTALLATION [MZR 2.5] FUEL I NJECTOR REMOVAL/INSTALLATION [MZR 2.5] FUEL I NJECTOR INSPECTION [MZR 2.5]

FUEL SYSTEM

FUEL SYSTEM LOCATION INDEX [MZI 3.7 V6] FUEL SYSTEM DIAGRAM [MZI 3.7 V6] BEFORE SERVICE PRECAUTION [MZI 3.7 V6] AFTER SERVICE PRECAUTION [MZI 3.7 V6] FUEL LINE PRESSURE INSPECTION [MZI 3.7 V6] FUEL TANK REMOVAL/INSTALLATION [MZI 3.7 V6] FUEL TANK INSPECTION [MZI 3.7 V6] NON-RETURN VALVE INSPECTION [MZI 3.7 V6] FUEL PUMP UNIT REMOVAL/INSTALLATION [MZI 3.7 V6] FUEL PUMP UNIT DISASSEMBLY/ASSEMBLY [MZI 3.7 V6] FUEL PUMP UNIT INSPECTION [MZI 3.7 V6] ELECTRONIC FUEL PUMP RELAY REMOVAL/INSTALLATION [MZI 3.7 V6] QUICK RELEASE CONNECTOR REMOVAL/INSTALLATION [MZI 3.7 V6] FUEL I NJECTOR REMOVAL/INSTALLATION [MZI 3.7 V6] FUEL I NJECTOR INSPECTION [MZI 3.7 V6]

EXHAUST SYSTEM

EXHAUST SYSTEM INSPECTION [MZR 2.5] EXHAUST SYSTEM REMOVAL/INSTALLATION [MZR 2.5]

EXHAUST SYSTEM

EXHAUST SYSTEM INSPECTION [MZI 3.7 V6] EXHAUST SYSTEM REMOVAL/INSTALLATION [MZI 3.7 V6]

EMISSION SYSTEM

EMISSION SYSTEM LOCATION INDEX [MZR 2.5] EMISSION SYSTEM DIAGRAM [MZR 2.5] FUEL-FILLER CAP INSPECTION [MZR 2.5] PURGE SOLENOID VALVE REMOVAL/INSTALLATION [MZR 2.5] PURGE SOLENOID VALVE INSPECTION [MZR 2.5] EGR VALVE REMOVAL/INSTALLATION [MZR 2.5] EGR VALVE INSPECTION [MZR 2.5] POSI TI VE CRANKCASE VENTI LATI ON (PCV) VALVE REMOVAL/INSTALLATION [MZR 2.5] POSI TI VE CRANKCASE VENTI LATI ON (PCV) VALVE INSPECTION [MZR 2.5] ROLLOVER VALVE REMOVAL/INSTALLATION [MZR 2.5] ROLLOVER VALVE INSPECTION [MZR 2.5] FUEL SHUT-OFF VALVE REMOVAL/INSTALLATION [MZR 2.5] FUEL SHUT-OFF VALVE INSPECTION [MZR 2.5] QUICK RELEASE CONNECTOR (EMISSION SYSTEM) REMOVAL/INSTALLATION [MZR 2.5] EVAPORATI VE CHAMBER REMOVAL/INSTALLATION [MZR 2.5] EVAPORATI VE CHAMBER INSPECTION [MZR 2.5] CHARCOAL CANISTER, CANISTER VENT (CV) SOLENOID VALVE, AIR FILTER COMPONENT REMOVAL/INSTALLATION [MZR 2.5] CHARCOAL CANISTER, CANISTER VENT (CV) SOLENOID VALVE, AIR FILTER COMPONENT INSPECTION [MZR 2.5]

EMISSION SYSTEM

EMISSION SYSTEM LOCATION INDEX [MZI 3.7 V6] EMISSION SYSTEM DIAGRAM [MZI 3.7 V6] FUEL-FILLER CAP INSPECTION [MZI 3.7 V6] PURGE SOLENOID VALVE REMOVAL/INSTALLATION [MZI 3.7 V6] PURGE SOLENOID VALVE INSPECTION [MZI 3.7 V6] POSI TI VE CRANKCASE VENTI LATI ON (PCV) VALVE REMOVAL/INSTALLATION [MZI 3.7 V6] POSI TI VE CRANKCASE VENTI LATI ON (PCV) VALVE INSPECTION [MZI 3.7 V6] POSI TI VE CRANKCASE VENTI LATI ON (PCV) FI TTI NG INSPECTION [MZI 3.7 V6] POSI TI VE CRANKCASE VENTI LATI ON (PCV) FI TTI NG REMOVAL/INSTALLATION [MZI 3.7 V6] ROLLOVER VALVE REMOVAL/INSTALLATION [MZI 3.7 V6] ROLLOVER VALVE INSPECTION [MZI 3.7 V6] FUEL SHUT-OFF VALVE REMOVAL/INSTALLATION [MZI 3.7 V6] FUEL SHUT-OFF VALVE INSPECTION [MZI 3.7 V6] QUICK RELEASE CONNECTOR (EMISSION SYSTEM) REMOVAL/INSTALLATION [MZI 3.7 V6] EVAPORATI VE CHAMBER REMOVAL/INSTALLATION [MZI 3.7 V6] EVAPORATI VE CHAMBER INSPECTION [MZI 3.7 V6] CHARCOAL CANISTER, CANISTER VENT (CV) SOLENOID VALVE, AIR FILTER COMPONENT REMOVAL/INSTALLATION [MZI 3.7 V6] CHARCOAL CANISTER, CANISTER VENT (CV) SOLENOID VALVE, AIR FILTER COMPONENT INSPECTION [MZI 3.7 V6]

CHARGING SYSTEM

CHARGING SYSTEM LOCATION INDEX [MZR 2.5] BATTERY REMOVAL/INSTALLATION [MZR 2.5] BATTERY INSPECTION [MZR 2.5] BATTERY RECHARGI NG [MZR 2.5] GENERATOR REMOVAL/INSTALLATION [MZR 2.5] GENERATOR INSPECTION [MZR 2.5] GENERATOR DISASSEMBLY/ASSEMBLY [MZR 2.5]

CHARGING SYSTEM

CHARGING SYSTEM LOCATION INDEX [MZI 3.7 V6] BATTERY REMOVAL/INSTALLATION [MZI 3.7 V6] BATTERY INSPECTION [MZI 3.7 V6] BATTERY RECHARGI NG [MZI 3.7 V6] GENERATOR REMOVAL/INSTALLATION [MZI 3.7 V6] GENERATOR INSPECTION [MZI 3.7 V6] GENERATOR DISASSEMBLY/ASSEMBLY [MZI 3.7 V6]

IGNITION SYSTEM

IGNITION SYSTEM LOCATION INDEX [MZR 2.5] IGNITION COIL REMOVAL/INSTALLATION [MZR 2.5] IGNITION COIL INSPECTION [MZR 2.5] SPARK PLUG REMOVAL/INSTALLATION [MZR 2.5] SPARK PLUG INSPECTION [MZR 2.5]

IGNITION SYSTEM

IGNITION SYSTEM LOCATION INDEX [MZI 3.7 V6] IGNITION COIL REMOVAL/INSTALLATION [MZI 3.7 V6] IGNITION COIL INSPECTION [MZI 3.7 V6] SPARK PLUG REMOVAL/INSTALLATION [MZI 3.7 V6] SPARK PLUG INSPECTION [MZI 3.7 V6]

STARTING SYSTEM

STARTI NG SYSTEM LOCATION INDEX [MZR 2.5] STARTER REMOVAL/INSTALLATION [MZR 2.5] STARTER INSPECTION [MZR 2.5] STARTER DISASSEMBLY/ASSEMBLY [MZR 2.5] STARTER INTERLOCK SWITCH INSPECTION [MZR 2.5]

STARTING SYSTEM

STARTI NG SYSTEM LOCATION INDEX [MZI 3.7 V6] STARTER REMOVAL/INSTALLATION [MZI 3.7 V6] STARTER INSPECTION [MZI 3.7 V6] STARTER DISASSEMBLY/ASSEMBLY [MZI 3.7 V6]

CRUISE CONTROL SYSTEM

CRUI SE CONTROL SWITCH INSPECTION [MZR 2.5]

CRUISE CONTROL SYSTEM

CRUI SE CONTROL SWITCH INSPECTION [MZI 3.7 V6]

CONTROL SYSTEM

CONTROL SYSTEM LOCATION INDEX [MZR 2.5] CONTROL SYSTEM DIAGRAM [MZR 2.5] CONTROL SYSTEM WIRING DIAGRAM [MZR 2.5] PCM REMOVAL/INSTALLATION [MZR 2.5] PCM INSPECTION [MZR 2.5] PCM CONFIGURATION [MZR 2.5] CLUTCH PEDAL POSITION (CPP) SWITCH INSPECTION [MZR 2.5] NEUTRAL SWITCH INSPECTION [MZR 2.5] POWER STEERING PRESSURE (PSP) SWITCH INSPECTION [MZR 2.5] VARIABLE TUMBLE SHUTTER VALVE POSITION SENSOR INSPECTION [MZR 2.5] ENGINE COOLANT TEMPERATURE (ECT) SENSOR REMOVAL/INSTALLATION [MZR 2.5] ENGINE COOLANT TEMPERATURE (ECT) SENSOR INSPECTION [MZR 2.5] MASS AIR FLOW (MAF) SENSOR INSPECTION [MZR 2.5] INTAKE AIR TEMPERATURE (I AT) SENSOR INSPECTION [MZR 2.5] MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR REMOVAL/INSTALLATION [MZR 2.5] MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR INSPECTION [MZR 2.5] BAROMETRIC PRESSURE (BARO) SENSOR REMOVAL/INSTALLATION [MZR 2.5] BAROMETRIC PRESSURE (BARO) SENSOR INSPECTION [MZR 2.5] THROTTLE POSITION (TP) SENSOR INSPECTION [MZR 2.5] ACCELERATOR PEDAL POSITION (APP) SENSOR INSPECTION [MZR 2.5] AIR FUEL RATIO (A/F) SENSOR REMOVAL/INSTALLATION [MZR 2.5] AIR FUEL RATIO (A/F) SENSOR INSPECTION [MZR 2.5] HEATED OXYGEN SENSOR (HO2 S) REMOVAL/INSTALLATION [MZR 2.5] HEATED OXYGEN SENSOR (HO2 S) INSPECTION [MZR 2.5] CRANKSHAFT POSITION (CKP) SENSOR REMOVAL/INSTALLATION [MZR 2.5] CRANKSHAFT POSITION (CKP) SENSOR INSPECTION [MZR 2.5] CAMSHAFT POSITION (CMP) SENSOR REMOVAL/INSTALLATION [MZR 2.5] CAMSHAFT POSITION (CMP) SENSOR INSPECTION [MZR 2.5] KNOCK SENSOR (KS) REMOVAL/INSTALLATION [MZR 2.5] KNOCK SENSOR (KS) INSPECTION [MZR 2.5] FUEL TANK PRESSURE SENSOR INSPECTION [MZR 2.5]

CONTROL SYSTEM

CONTROL SYSTEM LOCATION INDEX [MZI 3.7 V6] CONTROL SYSTEM DIAGRAM [MZI 3.7 V6] CONTROL SYSTEM WIRING DIAGRAM [MZI 3.7 V6] PCM REMOVAL/INSTALLATION [MZI 3.7 V6] PCM INSPECTION [MZI 3.7 V6] PCM CONFIGURATION [MZI 3.7 V6] POWER STEERING PRESSURE (PSP) SWITCH INSPECTION [MZI 3.7 V6] MASS AIR FLOW (MAF)/INTAKE AIR TEMPERATURE (I AT) SENSOR REMOVAL/INSTALLATION [MZI 3.7 V6] MASS AIR FLOW (MAF) SENSOR INSPECTION [MZI 3.7 V6] INTAKE AIR TEMPERATURE (I AT) SENSOR INSPECTION [MZI 3.7 V6] THROTTLE POSITION (TP) SENSOR INSPECTION [MZI 3.7 V6] ACCELERATOR PEDAL POSITION (APP) SENSOR INSPECTION [MZI 3.7 V6] AIR FUEL RATIO (A/F) SENSOR REMOVAL/INSTALLATION [MZI 3.7 V6] AIR FUEL RATIO (A/F) SENSOR INSPECTION [MZI 3.7 V6] HEATED OXYGEN SENSOR (HO2 S) REMOVAL/INSTALLATION [MZI 3.7 V6] HEATED OXYGEN SENSOR (HO2 S) INSPECTION [MZI 3.7 V6] CRANKSHAFT POSITION (CKP) SENSOR REMOVAL/INSTALLATION [MZI 3.7 V6] CRANKSHAFT POSITION (CKP) SENSOR INSPECTION [MZI 3.7 V6] CAMSHAFT POSITION (CMP) SENSOR REMOVAL/INSTALLATION [MZI 3.7 V6] CAMSHAFT POSITION (CMP) SENSOR INSPECTION [MZI 3.7 V6] KNOCK SENSOR (KS) REMOVAL/INSTALLATION [MZI 3.7 V6] KNOCK SENSOR (KS) INSPECTION [MZI 3.7 V6] CYLINDER HEAD TEMPERATURE (CHT) SENSOR REMOVAL/INSTALLATION [MZI 3.7 V6] CYLINDER HEAD TEMPERATURE (CHT) SENSOR INSPECTION [MZI 3.7 V6] FUEL TANK PRESSURE SENSOR INSPECTION [MZI 3.7 V6]

TECHNICAL DATA

ENGINE TECHNICAL DATA [MZR 2.5]

TECHNICAL DATA

ENGINE TECHNICAL DATA [MZI 3.7 V6]

MAINTENANCE/SERVICE TOOLS

ENGINE SST [MZR 2.5]

MAINTENANCE/SERVICE TOOLS

ENGINE SST [MZI 3.7 V6]

Workshop MANUAL-SUSPENSION

ON-BOARD DIAGNOSTICS

TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING DIAGRAM TIRE PRESSURE MONITORING SYSTEM (TPMS) ON-BOARD DIAGNOSIS MALFUNCTIONING WHEEL UNIT IDENTIFICATION DTC C0 07 7: 00 DTC C2 01 1: 49/C2 01 2: 49/C2 01 3: 49/C2 01 4: 49 DTC C2 01 1: 87/C2 01 2: 87/C2 01 3: 87/C2 01 4: 87 DTC U0 12 7: 00 DTC U0 30 0: 00 DTC U3 00 0: 42

SYMPTOM TROUBLESHOOTING

SYSTEM WIRING DIAGRAM FOREWORD PRECAUTION SYMPTOM TROUBLESHOOTING NO.1 TPMS WARNING LIGHT ILLUMINATES CONTINUOUSLY NO.2 TPMS WARNING LIGHT (LOW PRESSURE WARNING) ILLUMINATES AFTER ENGINE START AND TURNS OFF AFTER DRI VI NG FOR PERI OD OF TI ME NO.3 WHEEL UNIT ID REGISTRATION CANNOT BE PERFORMED (TPMS WARNING LIGHT FLASHES)

GENERAL PROCEDURES

GENERAL PROCEDURES (SUSPENSION)

WHEEL ALIGNMENT

WHEEL ALIGNMENT PRE-INSPECTION FRONT WHEEL ALIGNMENT REAR WHEEL ALIGNMENT

WHEEL AND TIRES

WHEEL AND TIRE SPECIFICATION WHEEL AND TIRE SPECIFICATION [GENERAL (L.H.D.) specs.] WHEEL BALANCE ADJUSTMENT TIRE PRESSURE ADJUSTMENT (WITH TPMS) WHEEL UNIT ID REGISTRATION WHEEL UNIT REMOVAL/INSTALLATION

FRONT SUSPENSION

FRONT SUSPENSION LOCATION INDEX FRONT SHOCK ABSORBER AND COIL SPRING REMOVAL/INSTALLATION FRONT SHOCK ABSORBER AND COIL SPRING DISASSEMBLY/ASSEMBLY FRONT SHOCK ABSORBER INSPECTION FRONT SHOCK ABSORBER DISPOSAL FRONT UPPER ARM REMOVAL/INSTALLATION FRONT UPPER ARM INSPECTION FRONT LOWER ARM REMOVAL/INSTALLATION FRONT LOWER ARM INSPECTION FRONT STABILIZER REMOVAL/INSTALLATION FRONT STABILIZER CONTROL LINK INSPECTION FRONT CROSSMEMBER REMOVAL/INSTALLATION [MZR 2.5] FRONT CROSSMEMBER REMOVAL/INSTALLATION [MZI 3.7 V6] TRANSVERSE MEMBER REMOVAL/INSTALLATION

REAR SUSPENSION

REAR SUSPENSION LOCATION INDEX REAR SHOCK ABSORBER REMOVAL/INSTALLATION REAR SHOCK ABSORBER INSPECTION REAR SHOCK ABSORBER DISPOSAL REAR COIL SPRING REMOVAL/INSTALLATION REAR LOWER ARM REMOVAL/INSTALLATION REAR UPPER ARM REMOVAL/INSTALLATION REAR TRAI LI NG LINK REMOVAL/INSTALLATION REAR LATERAL LINK REMOVAL/INSTALLATION REAR STABILIZER REMOVAL/INSTALLATION REAR STABILIZER CONTROL LINK INSPECTION REAR CROSSMEMBER REMOVAL/INSTALLATION

TECHNICAL DATA

SUSPENSION TECHNICAL DATA SUSPENSION TECHNICAL DATA [GENERAL (L.H.D.) specs.]

MAINTENANCE/SERVICE TOOLS

SUSPENSION

Workshop MANUAL-DRIVELINE/AXLE

GENERAL PROCEDURES

GENERAL PROCEDURES (FRONT AND REAR AXLES)

FRONT AXLE

FRONT AXLE LOCATION INDEX WHEEL HUB, STEERING KNUCKLE INSPECTION WHEEL HUB, STEERING KNUCKLE REMOVAL/INSTALLATION WHEEL HUB, STEERING KNUCKLE DISASSEMBLY/ASSEMBLY FRONT WHEEL HUB BOLT REPLACEMENT

REAR AXLE

REAR AXLE LOCATION INDEX WHEEL HUB COMPONENT INSPECTION WHEEL HUB COMPONENT REMOVAL/INSTALLATION REAR WHEEL HUB BOLT REPLACEMENT

DRIVE SHAFT

DRIVE SHAFT LOCATION INDEX DRIVE SHAFT INSPECTION DRIVE SHAFT REMOVAL/INSTALLATION DRIVE SHAFT (TRI POD JOINT) DISASSEMBLY/ASSEMBLY DRIVE SHAFT (DOUBLE OFFSET JOINT) DISASSEMBLY/ASSEMBLY JOINT SHAFT INSPECTION JOINT SHAFT REMOVAL/INSTALLATION JOINT SHAFT DISASSEMBLY [MZR 2.5] JOINT SHAFT DISASSEMBLY [MZI 3.7 V6] JOINT SHAFT ASSEMBLY [MZR 2.5] JOINT SHAFT ASSEMBLY [MZI 3.7 V6]

TECHNICAL DATA

DRIVELINE/AXLE TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

DRIVELINE/AXLE SST

ON-BOARD DIAGNOSTICS

DYNAMIC STABILITY CONTROL SYSTEM WIRING DIAGRAM [DYNAMIC STABILITY CONTROL (DSC)] ON-BOARD DIAGNOSIS [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 00 1: 01/C0 00 3: 01/C0 01 0: 01/C0 01 1: 01/C0 01 4: 01/C0 01 5: 01/C0 01 8: 01/C0 01 9: 01/C0 01 C: 01/C0 01 D: 01 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 02 0: 01/C0 02 0: 11/C0 02 0: 13/C0 02 0: 16/C0 02 0: 1C/C0 02 0: 71 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 03 1: 01/C0 03 1: 13/C0 03 4: 01/C0 03 4: 13/C0 03 7: 01/C0 03 7: 13/C0 03 A: 01/C0 03 A: 13 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 03 1: 23/C0 03 1: 27/C0 03 1: 62/C0 03 4: 23/C0 03 4: 27/C0 03 4: 62/C0 03 7: 23/C0 03 7: 27/C0 03 7: 62/C0 03 A: 23/C0 03 A: 27/C0 03 A: 62 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 04 0: 13/C0 04 0: 64 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 04 4: 14/C0 04 4: 1C/C0 04 4: 65/C0 04 4: 66/C0 04 4: 67 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 05 1: 54 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 06 1: 28/C0 06 1: 62/C0 06 2: 27/C0 06 2: 28/C0 06 2: 29/C0 06 2: 62/C0 06 2: 65/C0 06 3: 27/C0 06 3: 28/C0 06 3: 61/C0 06 3: 62/C0 06 A: 61/C1 A9 7: 27/C1 A9 7: 28/C1 A9 7: 29/C1 A9 8: 27/C1 A9 8: 28/C1 A9 8: 29 [DYNAMIC STABILITY CONTROL (DSC)] DTC C0 08 9: 11 [DYNAMIC STABILITY CONTROL (DSC)] DTC C1 13 7: 64 [DYNAMIC STABILITY CONTROL (DSC)] DTC C1 A7 7: 12/C1 A7 7: 13/C1 A7 7: 16 [DYNAMIC STABILITY CONTROL (DSC)] DTC U0 02 8: 87 [DYNAMIC STABILITY CONTROL (DSC)] DTC U0 40 1: 00/U0 40 1: 68 [DYNAMIC STABILITY CONTROL (DSC)] DTC U0 40 2: 00 [DYNAMIC STABILITY CONTROL (DSC)] DTC U0 42 2: 00/U0 42 2: 28/U0 42 2: 64/U0 42 2: 86 [DYNAMIC STABILITY CONTROL (DSC)] DTC U0423: 29/U0423: 7B [DYNAMIC STABILITY CONTROL (DSC)] DTC U2 10 0: 00 [DYNAMIC STABILITY CONTROL (DSC)] DTC U3 00 0: 4A [DYNAMIC STABILITY CONTROL (DSC)] DTC U3 00 0: 96 [DYNAMIC STABILITY CONTROL (DSC)] DTC U3003: 16/U3003: 17/U3003: 1C [DYNAMIC STABILITY CONTROL (DSC)]

SYMPTOM TROUBLESHOOTING

SYSTEM WIRING DIAGRAM [DYNAMIC STABILITY CONTROL (DSC)] FOREWORD [DYNAMIC STABILITY CONTROL (DSC)] PRECAUTION [DYNAMIC STABILITY CONTROL (DSC)] SYMPTOM TROUBLESHOOTING [DYNAMIC STABILITY CONTROL (DSC)] NO.1 ANY OF THE FOLLOWING LIGHTS DO NOT ILLUMINATE WITH SWITCH THE IGNITION TO ON: (ABS WARNING LIGHT, BRAKE SYSTEM WARNING LIGHT, DSC INDICATOR LIGHT AND/OR DSC OFF LIGHT) [DYNAMIC STABILITY CONTROL (DSC)] NO.2 ANY OF THE FOLLOWING LIGHTS STAY ON: (ABS WARNING LIGHT, BRAKE SYSTEM WARNING LIGHT, DSC INDICATOR LIGHT AND/OR DSC OFF LIGHT) [DYNAMIC STABILITY CONTROL (DSC)] NO.3 THERE IS A MALFUNCTION IN THE SYSTEM EVEN THOUGH ABS WARNING LIGHT, BRAKE SYSTEM WARNING LIGHT, DSC INDICATOR LIGHT AND DSC OFF LIGHT DO NOT ILLUMINATE [DYNAMIC STABILITY CONTROL (DSC)] NO.4 ABS OR TCS* 1 OPERATES FREQUENTLY/TCS DOES NOT WORK CORRECTLY * 1: DSC SYSTEM FUNCTION CONTAI NS TRACTION CONTROL FUNCTION, DSC INDICATOR LIGHT GOES ON AND OFF WHILE DSC OPERATES [DYNAMIC STABILITY CONTROL (DSC)] NO.5 DSC* 2 OPERATES FREQUENTLY/DSC DOES NOT WORK CORRECTLY * 2: DSC INDICATOR LIGHT GOES ON AND OFF WHILE DSC OPERATES [DYNAMIC STABILITY CONTROL (DSC)] NO.6 DSC INDICATOR LIGHT FLASHES (WHEN NEI THER THE TCS NOR THE DSC ARE OPERATING) [DYNAMIC STABILITY CONTROL (DSC)]

GENERAL PROCEDURES

GENERAL PROCEDURES (BRAKE)

CONVENTIONAL BRAKE SYSTEM

CONVENTIONAL BRAKE SYSTEM LOCATION INDEX BRAKE FLUID INSPECTION BRAKE FLUID AIR BLEEDING VACUUM LINE INSPECTION VACUUM HOSE REMOVAL/INSTALLATION BRAKE PEDAL INSPECTION BRAKE PEDAL REMOVAL/INSTALLATION BRAKE SWITCH INSPECTION MASTER CYLINDER REMOVAL/INSTALLATION BRAKE FLUID LEVEL SENSOR INSPECTION POWER BRAKE UNIT INSPECTION POWER BRAKE UNIT REMOVAL/INSTALLATION FRONT BRAKE (DISC) INSPECTION FRONT BRAKE (DISC) REMOVAL/INSTALLATION DISC PAD (FRONT) REPLACEMENT CALIPER (FRONT) DISASSEMBLY/ASSEMBLY BRAKE HOSE (FRONT) REMOVAL/INSTALLATION REAR BRAKE (DISC) INSPECTION REAR BRAKE (DISC) REMOVAL/INSTALLATION DISC PAD (REAR) REPLACEMENT CALIPER (REAR) DISASSEMBLY/ASSEMBLY BRAKE HOSE (REAR) REMOVAL/INSTALLATION

PARKING BRAKE SYSTEM

PARKING BRAKE SYSTEM LOCATION INDEX PARKING BRAKE SYSTEM LOCATION INDEX [GENERAL [L.H.D.] specs.] PARKING BRAKE LEVER INSPECTION PARKING BRAKE LEVER ADJUSTMENT PARKING BRAKE LEVER REMOVAL/INSTALLATION PARKING BRAKE LEVER REMOVAL/INSTALLATION [GENERAL [L.H.D.] specs.] FRONT PARKING BRAKE CABLE REMOVAL/INSTALLATION FRONT PARKING BRAKE CABLE REMOVAL/INSTALLATION [GENERAL [L.H.D.] specs.] REAR PARKING BRAKE CABLE REMOVAL/INSTALLATION REAR PARKING BRAKE CABLE REMOVAL/INSTALLATION [GENERAL [L.H.D.] specs.] PARKING BRAKE SWITCH INSPECTION

DYNAMIC STABILITY CONTROL

DSC LOCATION INDEX DSC SYSTEM WIRING DIAGRAM DSC HU/CM REMOVAL/INSTALLATION DSC CONFIGURATION DSC HU/CM INSPECTION FRONT ABS WHEEL-SPEED SENSOR REMOVAL/INSTALLATION FRONT ABS WHEEL-SPEED SENSOR INSPECTION REAR ABS WHEEL-SPEED SENSOR REMOVAL/INSTALLATION REAR ABS WHEEL-SPEED SENSOR INSPECTION BRAKE FLUID PRESSURE SENSOR INSPECTION DSC OFF SWITCH REMOVAL/INSTALLATION DSC OFF SWITCH INSPECTION

TECHNICAL DATA

BRAKES TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

BRAKES SST

Workshop MANUAL-TRANSMISSION/TRANSAXLE

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC SYSTEM WIRING DIAGRAM [FS5A-EL] ON-BOARD DIAGNOSTIC SYSTEM DTC INSPECTION [FS5A-EL] ON-BOARD DIAGNOSTIC SYSTEM DTC TABLE [FS5A-EL] DTC P0 6 B8: 00 [FS5A-EL] DTC P0 70 6: 00 [FS5A-EL] DTC P0 70 7: 00 [FS5A-EL] DTC P0 70 8: 00 [FS5A-EL] DTC P0 71 1: 00 [FS5A-EL] DTC P0 71 2: 00 [FS5A-EL] DTC P0 71 3: 00 [FS5A-EL] DTC P0 71 5: 00 [FS5A-EL] DTC P0 72 0: 00 [FS5A-EL] DTC P0 73 1: 00 [FS5A-EL] DTC P0 73 2: 00 [FS5A-EL] DTC P0 73 3: 00 [FS5A-EL] DTC P0 73 4: 00 [FS5A-EL] DTC P0 73 5: 00 [FS5A-EL] DTC P0 74 1: 00 [FS5A-EL] DTC P0 74 2: 00 [FS5A-EL] DTC P0 74 4: 00 [FS5A-EL] DTC P0 74 5: 00 [FS5A-EL] DTC P0 75 1: 00 [FS5A-EL] DTC P0 75 2: 00 [FS5A-EL] DTC P0 75 3: 00 [FS5A-EL] DTC P0 75 6: 00 [FS5A-EL] DTC P0 75 7: 00 [FS5A-EL] DTC P0 75 8: 00 [FS5A-EL] DTC P0 76 1: 00 [FS5A-EL] DTC P0 76 2: 00 [FS5A-EL] DTC P0 76 3: 00 [FS5A-EL] DTC P0 76 6: 00 [FS5A-EL] DTC P0 76 7: 00 [FS5A-EL] DTC P0 76 8: 00 [FS5A-EL] DTC P0 77 1: 00 [FS5A-EL] DTC P0 77 2: 00 [FS5A-EL] DTC P0 77 3: 00 [FS5A-EL] DTC P0 77 7: 00 [FS5A-EL] DTC P0 77 8: 00 [FS5A-EL] DTC P0 79 1: 00 [FS5A-EL] DTC P0 84 1: 00 [FS5A-EL] DTC P0 88 2: 00 [FS5A-EL] DTC P0 88 3: 00 [FS5A-EL] DTC P0 88 4: 00 [FS5A-EL] DTC P0 89 4: 00 [FS5A-EL] DTC P1 71 2: 00 [FS5A-EL] DTC P1 78 3: 00 [FS5A-EL] DTC P2 70 7: 00 [FS5A-EL] DTC P2 70 8: 00 [FS5A-EL] DTC P2 70 9: 00 [FS5A-EL] DTC U0 40 1: 00 [FS5A-EL] DTC U0 41 5: 00 [FS5A-EL] ON-BOARD DIAGNOSTIC SYSTEM PID/DATA MONI TOR INSPECTION [FS5A-EL] ON-BOARD DIAGNOSTIC SYSTEM SI MULATI ON INSPECTION [FS5A-EL]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC SYSTEM WIRING DIAGRAM [AY6A-EL] ON-BOARD DIAGNOSTIC SYSTEM DTC INSPECTION [AY6A-EL] ON-BOARD DIAGNOSTIC SYSTEM DTC TABLE [AY6A-EL] DTC P0 22 0: 00 [AY6A-EL] DTC P0 60 1: 00 [AY6A-EL] DTC P0 60 3: 00 [AY6A-EL] DTC P0 60 4: 00 [AY6A-EL] DTC P0 70 2: 00 [AY6A-EL] DTC P0 70 6: 00 [AY6A-EL] DTC P0 70 7: 00 [AY6A-EL] DTC P0 70 8: 00 [AY6A-EL] DTC P0 71 1: 00 [AY6A-EL] DTC P0 71 2: 00 [AY6A-EL] DTC P0 71 3: 00 [AY6A-EL] DTC P0 71 5: 00 [AY6A-EL] DTC P0 71 7: 00 [AY6A-EL] DTC P0 72 0: 00 [AY6A-EL] DTC P0 72 2: 00 [AY6A-EL] DTC P0 72 7: 00 [AY6A-EL] DTC P0 72 9: 00 [AY6A-EL] DTC P0 72 D: 00 [AY6A-EL] DTC P0 73 0: 00 [AY6A-EL] DTC P0 73 1: 00 [AY6A-EL] DTC P0 73 2: 00 [AY6A-EL] DTC P0 73 3: 00 [AY6A-EL] DTC P0 73 4: 00 [AY6A-EL] DTC P0 73 5: 00 [AY6A-EL] DTC P0 73 F: 00 [AY6A-EL] DTC P0 74 A: 00 [AY6A-EL] DTC P0 74 B: 00 [AY6A-EL] DTC P0 74 C: 00 [AY6A-EL] DTC P0 74 D: 00 [AY6A-EL] DTC P0 74 E: 00 [AY6A-EL] DTC P0 76 2: 00 [AY6A-EL] DTC P0 76 6: 00 [AY6A-EL] DTC P0 77 1: 00 [AY6A-EL] DTC P0 81 7: 00 [AY6A-EL] DTC P0 81 9: 00 [AY6A-EL] DTC P0 86 7: 00 [AY6A-EL] DTC P0 88 2: 00 [AY6A-EL] DTC P0 88 3: 00 [AY6A-EL] DTC P0 94 2: 00 [AY6A-EL] DTC P0 96 1: 00 [AY6A-EL] DTC P0 96 2: 00 [AY6A-EL] DTC P0 96 3: 00 [AY6A-EL] DTC P0 97 3: 00 [AY6A-EL] DTC P0 97 4: 00 [AY6A-EL] DTC P0 97 6: 00 [AY6A-EL] DTC P0 97 7: 00 [AY6A-EL] DTC P0 97 8: 00 [AY6A-EL] DTC P0 97 9: 00 [AY6A-EL] DTC P0 98 0: 00 [AY6A-EL] DTC P0 98 1: 00 [AY6A-EL] DTC P0 98 2: 00 [AY6A-EL] DTC P0 98 3: 00 [AY6A-EL] DTC P0 98 4: 00 [AY6A-EL] DTC P0 98 5: 00 [AY6A-EL] DTC P0 98 6: 00 [AY6A-EL] DTC P0 99 7: 00 [AY6A-EL] DTC P0 99 8: 00 [AY6A-EL] DTC P0 99 9: 00 [AY6A-EL] DTC P1 70 0: 00 [AY6A-EL] DTC P1 71 9: 00 [AY6A-EL] DTC P1 73 8: 00 [AY6A-EL] DTC P1 78 3: 00 [AY6A-EL] DTC P1 91 9: 00 [AY6A-EL] DTC P2 54 4: 00 [AY6A-EL] DTC P2 70 8: 00 [AY6A-EL] DTC P2 75 7: 00 [AY6A-EL] DTC P2 76 2: 00 [AY6A-EL] DTC P2 76 3: 00 [AY6A-EL] DTC P2 76 4: 00 [AY6A-EL] DTC P2 80 6: 00 [AY6A-EL] DTC U0 41 5: 00 [AY6A-EL] ON-BOARD DIAGNOSTIC SYSTEM PID/DATA MONI TOR INSPECTION [AY6A-EL] ON-BOARD DIAGNOSTIC SYSTEM SI MULATI ON INSPECTION [AY6A-EL]

SYMPTOM TROUBLESHOOTING

AUTOMATIC TRANSAXLE CONTROL SYSTEM WIRING DIAGRAM [FS5A-EL] FOREWORD [FS5A-EL] BASIC INSPECTION [FS5A-EL] SYMPTOM TROUBLESHOOTING I TEM TABLE [FS5A-EL] QUICK DIAGNOSIS CHART [FS5A-EL] NO.1 VEHICLE DOES NOT MOVE IN D, M OR IN R POSITION [FS5A-EL] NO.2 VEHICLE MOVES IN N POSITION [FS5A-EL] NO.3 VEHICLE MOVES IN P POSITION, OR PARKING GEAR DOES NOT DISENGAGE WHEN P IS DI SENGAGED [FS5A-EL] NO.4 EXCESSIVE CREEP [FS5A-EL] NO.5 NO CREEP AT ALL [FS5A-EL] NO.6 LOW MAXI MUM SPEED AND POOR ACCELERATION [FS5A-EL] NO.7 NO SHI FTI NG [FS5A-EL] NO.8 DOES NOT SHIFT TO 5 GR [FS5A-EL] NO.9 ABNORMAL SHI FTI NG [FS5A-EL] NO.10 FREQUENT SHI FTI NG [FS5A-EL] NO.11 SHIFT POINT IS HIGH OR LOW [FS5A-EL] NO.12 TORQUE CONVERTER CLUTCH (TCC) NON-OPERATION [FS5A-EL] NO.13 NO KICKDOWN [FS5A-EL] NO.14 ENGINE FLARES UP OR SLIPS WHEN UPSHIFTING OR DOWNSHIFTING [FS5A-EL] NO.15 ENGINE FLARES UP OR SLIPS WHEN ACCELERATING VEHICLE [FS5A-EL] NO.16 JUDDER UPON TORQUE CONVERTER CLUTCH (TCC) OPERATION [FS5A-EL] NO.17 EXCESSIVE SHIFT SHOCK FROM N TO D OR N TO R POSITION [FS5A-EL] NO.18 EXCESSIVE SHIFT SHOCK IS FELT WHEN UPSHIFTING AND DOWNSHIFTING [FS5A-EL] NO.19 EXCESSIVE SHIFT SHOCK ON TORQUE CONVERTER CLUTCH (TCC) [FS5A-EL] NO.20 NOISE OCCURS AT IDLE WHEN VEHICLE IS STOPPED IN ALL POSITIONS [FS5A-EL] NO.21 NOISE OCCURS AT IDLE WHEN VEHICLE IS STOPPED IN D, M OR IN R POSITION [FS5A-EL] NO.22 NO ENGINE BRAKING IN 1 GR POSITION OF M POSITION [FS5A-EL] NO.23 TRANSAXLE OVERHEATS [FS5A-EL] NO.24 ENGINE STALLS WHEN SHIFTED TO D, M OR IN R POSITION [FS5A-EL] NO.25 ENGINE STALLS WHEN DRI VI NG AT SLOW SPEEDS OR STOPPI NG [FS5A-EL] NO.26 STARTER DOES NOT WORK [FS5A-EL] NO.27 GEAR POSITION INDICATOR LIGHT DOES NOT ILLUMINATE IN M POSITION [FS5A-EL] NO.28 GEAR POSITION INDICATOR LIGHT ILLUMINATES IN P, R, N AND D POSITION [FS5A-EL] NO.29 DOES NOT UPSHIFT IN M POSITION [FS5A-EL] NO.30 DOES NOT DOWNSHIFT IN M POSITION [FS5A-EL] NO.31 M POSITION INDICATOR LIGHT DOES NOT ILLUMINATE IN M POSITION/M POSITION INDICATOR LIGHT ILLUMINATES IN D POSITION [FS5A-EL] NO.32 ATF SEEPI NG FROM AUTOMATIC TRANSAXLE [FS5A-EL]

SYMPTOM TROUBLESHOOTING

AUTOMATIC TRANSAXLE CONTROL SYSTEM WIRING DIAGRAM [AY6A-EL] FOREWORD [AY6A-EL] BASIC INSPECTION [AY6A-EL] SYMPTOM TROUBLESHOOTING I TEM TABLE [AY6A-EL] QUICK DIAGNOSIS CHART [AY6A-EL] NO.1 VEHICLE DOES NOT MOVE IN D OR IN R POSITION [AY6A-EL] NO.2 VEHICLE MOVES IN N POSITION [AY6A-EL] NO.3 VEHICLE MOVES IN P POSITION, OR PARKING GEAR DOES NOT DISENGAGE WHEN P IS DI SENGAGED [AY6A-EL] NO.4 EXCESSIVE CREEP [AY6A-EL] NO.5 NO CREEP AT ALL [AY6A-EL] NO.6 LOW MAXI MUM SPEED AND POOR ACCELERATION [AY6A-EL] NO.7 NO SHI FTI NG [AY6A-EL] NO.8 DOES NOT SHIFT TO 6 GR [AY6A-EL] NO.9 ABNORMAL SHI FTI NG [AY6A-EL] NO.10 FREQUENT SHI FTI NG [AY6A-EL] NO.11 SHIFT POINT IS HIGH OR LOW [AY6A-EL] NO.12 TORQUE CONVERTER CLUTCH (TCC) NON-OPERATION [AY6A-EL] NO.13 NO KICKDOWN [AY6A-EL] NO.14 ENGINE FLARES UP OR SLIPS WHEN UPSHIFTING OR DOWNSHIFTING [AY6A-EL] NO.15 ENGINE FLARES UP OR SLIPS WHEN ACCELERATING VEHICLE [AY6A-EL] NO.16 JUDDER UPON TORQUE CONVERTER CLUTCH (TCC) OPERATION [AY6A-EL] NO.17 EXCESSIVE SHIFT SHOCK FROM N TO D OR N TO R POSITION [AY6A-EL] NO.18 EXCESSIVE SHIFT SHOCK IS GI VEN WHEN UPSHIFTING AND DOWNSHIFTING [AY6A-EL] NO.19 EXCESSIVE SHIFT SHOCK ON TORQUE CONVERTER CLUTCH (TCC) [AY6A-EL] NO.20 NOISE OCCURS AT IDLE WHEN VEHICLE IS STOPPED IN ALL POSITIONS [AY6A-EL] NO.21 NOISE OCCURS AT IDLE WHEN VEHICLE IS STOPPED IN D OR IN R POSITION [AY6A-EL] NO.22 NO ENGINE BRAKING IN 1 GR POSITION OF M POSITION [AY6A-EL] NO.23 TRANSAXLE OVERHEATS [AY6A-EL] NO.24 ENGINE STALLS WHEN SHIFTED TO D OR IN R POSITION [AY6A-EL] NO.25 ENGINE STALLS WHEN DRI VI NG AT SLOW SPEED OR STOPPI NG [AY6A-EL] NO.26 STARTER DOES NOT WORK [AY6A-EL] NO.27 GEAR POSITION INDICATOR LIGHT DOES NOT ILLUMINATE IN D OR M POSITION [AY6A-EL] NO.28 GEAR POSITION INDICATOR LIGHT ILLUMINATE IN P, R OR N POSITION [AY6A-EL] NO.29 DOES NOT UPSHIFT IN M POSITION [AY6A-EL] NO.30 DOES NOT DOWNSHIFT IN M POSITION [AY6A-EL] NO.31 M POSITION INDICATOR LIGHT DOES NOT ILLUMINATE IN M POSITION/M POSITION INDICATOR LIGHT ILLUMINATES IN D POSITION [AY6A-EL]

CLUTCH

CLUTCH LOCATION INDEX [G6 6 M-R] CLUTCH FLUID INSPECTION [G6 6 M-R] CLUTCH FLUID AIR BLEEDING/REPLACEMENT [G6 6 M-R] CLUTCH PEDAL INSPECTION/ADJUSTMENT [G6 6 M-R] CLUTCH PEDAL REMOVAL/INSTALLATION [G6 6 M-R] CLUTCH MASTER CYLINDER REMOVAL/INSTALLATION [G6 6 M-R] CLUTCH MASTER CYLINDER DISASSEMBLY/ASSEMBLY [G6 6 M-R] CLUTCH RELEASE CYLINDER REMOVAL/INSTALLATION [G6 6 M-R] CLUTCH RELEASE CYLINDER DISASSEMBLY/ASSEMBLY [G6 6 M-R] CLUTCH UNIT REMOVAL/INSTALLATION [G6 6 M-R] CLUTCH COVER INSPECTION [G6 6 M-R] CLUTCH DISC INSPECTION [G6 6 M-R] CLUTCH RELEASE COLLAR INSPECTION [G6 6 M-R] PI LOT BEARI NG INSPECTION [G6 6 M-R] FLYWHEEL INSPECTION [G6 6 M-R]

MANUAL TRANSAXLE

MANUAL TRANSAXLE LOCATION INDEX [G6 6 M-R] NEUTRAL SWITCH REMOVAL/INSTALLATION [G6 6 M-R] BACK-UP LIGHT SWITCH REMOVAL/INSTALLATION [G6 6 M-R] TRANSAXLE OIL INSPECTION [G6 6 M-R] TRANSAXLE OIL REPLACEMENT [G6 6 M-R] OIL SEAL (DIFFERENTIAL) REPLACEMENT [G6 6 M-R] MANUAL TRANSAXLE REMOVAL/INSTALLATION [G6 6 M-R] INSPECTION AFTER TRANSAXLE INSTALLATION [G6 6 M-R]

MANUAL TRANSAXLE SHIFT MECHANISM

MANUAL TRANSAXLE SHIFT MECHANI SM LOCATION INDEX MANUAL TRANSAXLE SHIFT MECHANI SM REMOVAL/INSTALLATION

AUTOMATIC TRANSAXLE

AUTOMATIC TRANSAXLE LOCATION INDEX [FS5A-EL] MECHANI CAL SYSTEM TEST [FS5A-EL] ROAD TEST [FS5A-EL] AUTOMATIC TRANSAXLE FLUID (ATF) INSPECTION [FS5A-EL] AUTOMATIC TRANSAXLE FLUID (ATF) REPLACEMENT [FS5A-EL] TRANSAXLE RANGE (TR) SWITCH INSPECTION [FS5A-EL] TRANSAXLE RANGE (TR) SWITCH ADJUSTMENT [FS5A-EL] TRANSAXLE RANGE (TR) SWITCH REMOVAL/INSTALLATION [FS5A-EL] M POSITION SWITCH INSPECTION [FS5A-EL] M POSITION SWITCH REMOVAL/INSTALLATION [FS5A-EL] UP SWITCH INSPECTION [FS5A-EL] UP SWITCH REMOVAL/INSTALLATION [FS5A-EL] DOWN SWITCH INSPECTION [FS5A-EL] DOWN SWITCH REMOVAL/INSTALLATION [FS5A-EL] TRANSAXLE FLUID TEMPERATURE (TFT) SENSOR INSPECTION [FS5A-EL] TRANSAXLE FLUID TEMPERATURE (TFT) SENSOR REMOVAL/INSTALLATION [FS5A-EL] OIL PRESSURE SWITCH INSPECTION [FS5A-EL] OIL PRESSURE SWITCH REMOVAL/INSTALLATION [FS5A-EL] I NPUT/TURBI NE SPEED SENSOR INSPECTION [FS5A-EL] I NPUT/TURBI NE SPEED SENSOR REMOVAL/INSTALLATION [FS5A-EL] INTERMEDIATE SENSOR INSPECTION [FS5A-EL] INTERMEDIATE SENSOR REMOVAL/INSTALLATION [FS5A-EL] VEHICLE SPEED SENSOR (VSS) INSPECTION [FS5A-EL] VEHICLE SPEED SENSOR (VSS) REMOVAL/INSTALLATION [FS5A-EL] SOLENOID VALVE INSPECTION [FS5A-EL] SOLENOID VALVE REMOVAL/INSTALLATION [FS5A-EL] TCM INSPECTION [FS5A-EL] TCM REMOVAL/INSTALLATION [FS5A-EL] AUTOMATIC TRANSAXLE REMOVAL/INSTALLATION [FS5A-EL] DRIVE PLATE REMOVAL/INSTALLATION [FS5A-EL] OIL SEAL REPLACEMENT [FS5A-EL] OIL COOLER REMOVAL/INSTALLATION [FS5A-EL] OIL COOLER FLUSHI NG [FS5A-EL] CONTROL VALVE BODY REMOVAL/INSTALLATION [FS5A-EL]

AUTOMATIC TRANSAXLE

AUTOMATIC TRANSAXLE LOCATION INDEX [AY6A-EL] MECHANI CAL SYSTEM TEST [AY6A-EL] ROAD TEST [AY6A-EL] AUTOMATIC TRANSAXLE FLUID (ATF) INSPECTION [AY6A-EL] AUTOMATIC TRANSAXLE FLUID (ATF) REPLACEMENT [AY6A-EL] AUTOMATIC TRANSAXLE FLUID (ATF) LEVEL ADJUSTMENT [AY6A-EL] TRANSAXLE RANGE (TR) SWITCH INSPECTION [AY6A-EL] TRANSAXLE RANGE (TR) SWITCH REMOVAL/INSTALLATION [AY6A-EL] M POSITION SWITCH INSPECTION [AY6A-EL] M POSITION SWITCH REMOVAL/INSTALLATION [AY6A-EL] UP SWITCH INSPECTION [AY6A-EL] UP SWITCH REMOVAL/INSTALLATION [AY6A-EL] DOWN SWITCH INSPECTION [AY6A-EL] DOWN SWITCH REMOVAL/INSTALLATION [AY6A-EL] TRANSAXLE FLUID TEMPERATURE (TFT) SENSOR INSPECTION [AY6A-EL] TRANSAXLE FLUID TEMPERATURE (TFT) SENSOR REMOVAL/INSTALLATION [AY6A-EL] I NPUT/TURBI NE SPEED SENSOR INSPECTION [AY6A-EL] I NPUT/TURBI NE SPEED SENSOR REMOVAL/INSTALLATION [AY6A-EL] VEHICLE SPEED SENSOR (VSS) INSPECTION [AY6A-EL] VEHICLE SPEED SENSOR (VSS) REMOVAL/INSTALLATION [AY6A-EL] COUPLER COMPONENT INSPECTION [AY6A-EL] COUPLER COMPONENT REMOVAL/INSTALLATION [AY6A-EL] LINE PRESSURE CONTROL SOLENOID INSPECTION [AY6A-EL] LINE PRESSURE CONTROL SOLENOID REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID A INSPECTION [AY6A-EL] SHIFT SOLENOID A REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID B INSPECTION [AY6A-EL] SHIFT SOLENOID B REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID C INSPECTION [AY6A-EL] SHIFT SOLENOID C REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID D INSPECTION [AY6A-EL] SHIFT SOLENOID D REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID E INSPECTION [AY6A-EL] SHIFT SOLENOID E REMOVAL/INSTALLATION [AY6A-EL] SHIFT SOLENOID F INSPECTION [AY6A-EL] SHIFT SOLENOID F REMOVAL/INSTALLATION [AY6A-EL] TORQUE CONVERTER CLUTCH (TCC) CONTROL SOLENOID INSPECTION [AY6A-EL] TORQUE CONVERTER CLUTCH (TCC) CONTROL SOLENOID REMOVAL/INSTALLATION [AY6A-EL] TCM INSPECTION [AY6A-EL] TCM REMOVAL/INSTALLATION [AY6A-EL] TCM NEUTRAL POSITION LEARNI NG [AY6A-EL] BREATHER COMPONENT REMOVAL/INSTALLATION [AY6A-EL] B1 BRAKE PISTON COVER REMOVAL/INSTALLATION [AY6A-EL] OIL SEAL (MANUAL SHAFT) REPLACEMENT [AY6A-EL] OIL SEAL (DIFFERENTIAL) REPLACEMENT [AY6A-EL] DIFFERENTIAL GEAR O-RI NG REPLACEMENT [AY6A-EL] OIL COOLER FLUSHI NG [AY6A-EL] OIL COOLER REMOVAL/INSTALLATION [AY6A-EL] CONTROL VALVE BODY COVER REPLACEMENT [AY6A-EL] CONTROL VALVE BODY REMOVAL/INSTALLATION [AY6A-EL] AUTOMATIC TRANSAXLE REMOVAL/INSTALLATION [AY6A-EL] AUTOMATIC TRANSAXLE CLEANI NG [AY6A-EL] AUTOMATIC TRANSAXLE DISASSEMBLY/ASSEMBLY PRECAUTION [AY6A-EL] TORQUE CONVERTER REMOVAL/INSTALLATION [AY6A-EL] OIL SEAL (OIL PUMP) REPLACEMENT [AY6A-EL] CONVERTER HOUSI NG REMOVAL/INSTALLATION [AY6A-EL] OIL PUMP REMOVAL/INSTALLATION [AY6A-EL] OIL PUMP DISASSEMBLY/ASSEMBLY [AY6A-EL] OIL STRAI NER REMOVAL/INSTALLATION [AY6A-EL] FRONT PLANETARY GEAR COMPONENT AND I NPUT SHAFT REMOVAL/INSTALLATION [AY6A-EL] FRONT PLANETARY GEAR COMPONENT AND I NPUT SHAFT DISASSEMBLY/ASSEMBLY [AY6A-EL] DRIVE PLATE REMOVAL/INSTALLATION [AY6A-EL]

AUTOMATIC TRANSAXLE SHIFT MECHANISM

AUTOMATIC TRANSAXLE SHIFT MECHANI SM LOCATION INDEX AUTOMATIC TRANSAXLE SHIFT MECHANI SM REMOVAL/INSTALLATION SELECTOR LEVER INSPECTION SHIFT-LOCK SYSTEM INSPECTION KEY INTERLOCK SYSTEM INSPECTION

TECHNICAL DATA

TRANSMISSION/TRANSAXLE TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

TRANSMISSION/TRANSAXLE SST

Workshop MANUAL-STEERING

GENERAL PROCEDURES

GENERAL PROCEDURES (STEERING)

POWER STEERING

STEERING LOCATION INDEX AIR BLEEDING POWER STEERING FLUID INSPECTION STEERING WHEEL AND COLUMN INSPECTION STEERING WHEEL AND COLUMN REMOVAL/INSTALLATION [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] STEERING WHEEL AND COLUMN REMOVAL/INSTALLATION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] STEERING SHAFT INSPECTION STEERING GEAR AND LINKAGE REMOVAL/INSTALLATION [MZR 2.5] STEERING GEAR AND LINKAGE REMOVAL/INSTALLATION [MZI 3.7 V6] STEERING GEAR AND LINKAGE DISASSEMBLY STEERING GEAR AND LINKAGE INSPECTION STEERING GEAR AND LINKAGE ASSEMBLY POWER STEERING FLUID LINE COMPONENT REMOVAL/INSTALLATION [MZR 2.5] POWER STEERING FLUID LINE COMPONENT REMOVAL/INSTALLATION [MZI 3.7 V6] POWER STEERING OIL PUMP REMOVAL/INSTALLATION [MZR 2.5] POWER STEERING OIL PUMP REMOVAL/INSTALLATION [MZI 3.7 V6] POWER STEERING OIL PUMP DISASSEMBLY/ASSEMBLY [MZR 2.5] POWER STEERING OIL PUMP DISASSEMBLY/ASSEMBLY [MZI 3.7 V6]

TECHNICAL DATA

STEERING TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

STEERING SST

Workshop MANUAL-HVAC

ON-BOARD DIAGNOSTICS

HVAC SYSTEM WIRING DIAGRAM FOREWORD FLOW CHART DTC DISPLAY CLEARING DTC DTC TABLE DTC B1 08 1: 71 , B1 08 2: 71 DTC B1 08 6: 71 DTC B1 A6 1: 11 , B1 A6 1: 13 DTC B1 A6 3: 11 , B1 A6 3: 13 , B1 A6 4: 11 , B1 A6 4: 13 DTC B1 B7 1: 11 , B1 B7 1: 13 DTC B1 C1 A: 11 , B1 C1 A: 13 , B1 C1 B: 11 , B1 C1 B: 13 DTC B1 C1 C: 11 , B1 C1 C: 13 DTC U0423: 68 PID/DATA MONI TOR DISPLAY PID/DATA MONI TOR TABLE ACTIVE COMMAND MODES DISPLAY ACTIVE COMMAND MODES TABLE A/C OPERATION CHECK MODE DISPLAY A/C OPERATION CHECK MODE TABLE

SYMPTOM TROUBLESHOOTING

HVAC SYSTEM WIRING DIAGRAM [FULL-AUTO AIR CONDITIONER] FOREWORD [FULL-AUTO AIR CONDITIONER] TROUBLESHOOTING INDEX [FULL-AUTO AIR CONDITIONER] NO.1 INSUFFICIENT AIR (OR NO AIR) BLOWN FROM VENTS [FULL-AUTO AIR CONDITIONER] NO.2 AMOUNT OF AIR BLOWN FROM VENTS DOES NOT CHANGE [FULL-AUTO AIR CONDITIONER] NO.3 AMOUNT OF AIR BLOWN FROM REAR VENTS DOES NOT CHANGE [FULL-AUTO AIR CONDITIONER] NO.4 AIR INTAKE MODE FROM VENT DOES NOT CHANGE [FULL-AUTO AIR CONDITIONER] NO.5 NO TEMPERATURE CONTROL WITH CLIMATE CONTROL UNIT [FULL-AUTO AIR CONDITIONER] NO.6 WINDSHIELD FOGGED [FULL-AUTO AIR CONDITIONER] NO.7 AIR FROM VENTS NOT COLD ENOUGH [FULL-AUTO AIR CONDITIONER] NO.8 NO COOL AIR [FULL-AUTO AIR CONDITIONER] NO.9 NOISE WHILE OPERATING A/C SYSTEM [FULL-AUTO AIR CONDITIONER] NO.10 DUAL A/C CONTROL DOES NOT OPERATE [FULL-AUTO AIR CONDITIONER]

SYMPTOM TROUBLESHOOTING

HVAC SYSTEM WIRING DIAGRAM [MANUAL AIR CONDITIONER] FOREWORD [MANUAL AIR CONDITIONER] TROUBLESHOOTING INDEX [MANUAL AIR CONDITIONER] NO.1 INSUFFICIENT AIR (OR NO AIR) BLOWN FROM VENTS [MANUAL AIR CONDITIONER] NO.2 AMOUNT OF AIR BLOWN FROM VENTS DOES NOT CHANGE [MANUAL AIR CONDITIONER] NO.3 AIR INTAKE MODE DOES NOT CHANGE [MANUAL AIR CONDITIONER] NO.4 NO TEMPERATURE CONTROL WITH CLIMATE CONTROL UNIT [MANUAL AIR CONDITIONER] NO.5 WINDSHIELD FOGGED [MANUAL AIR CONDITIONER] NO.6 AIR FROM VENTS NOT COLD ENOUGH [MANUAL AIR CONDITIONER] NO.7 NO COOL AIR [MANUAL AIR CONDITIONER] NO.8 NOISE WHILE OPERATING A/C SYSTEM [MANUAL AIR CONDITIONER]

REFRIGERANT SYSTEM

REFRIGERANT SYSTEM SERVICE WARNINGS REFRIGERANT SYSTEM SERVICE CAUTIONS REFRIGERANT SYSTEM GENERAL PROCEDURES REFRIGERANT CHARGING REFRIGERANT RECOVERY REFRIGERANT PRESSURE CHECK REFRIGERANT SYSTEM PERFORMANCE TEST

BASIC SYSTEM

HVAC BASIC SYSTEM LOCATION INDEX AIR FILTER REMOVAL/INSTALLATION AIR FILTER INSPECTION A/C UNIT REMOVAL/INSTALLATION A/C UNIT DISASSEMBLY/ASSEMBLY EXPANSI ON VALVE REMOVAL/INSTALLATION EVAPORATOR INSPECTION HEATER CORE INSPECTION REAR HEAT DUCT COMPONENT REMOVAL/INSTALLATION A/C COMPRESSOR REMOVAL/INSTALLATION CONDENSER REMOVAL/INSTALLATION CONDENSER INSPECTION RECEIVER/DRI ER REMOVAL/INSTALLATION REFRIGERANT LINE REMOVAL/INSTALLATION

CONTROL SYSTEM

HVAC CONTROL SYSTEM LOCATION INDEX [FULL-AUTO AIR CONDITIONER] AIR INTAKE ACTUATOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] AIR INTAKE ACTUATOR INSPECTION [FULL-AUTO AIR CONDITIONER] AIR MIX ACTUATOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] AIR MIX ACTUATOR INSPECTION [FULL-AUTO AIR CONDITIONER] AI RFLOW MODE ACTUATOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] AI RFLOW MODE ACTUATOR INSPECTION [FULL-AUTO AIR CONDITIONER] FRONT BLOWER MOTOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] FRONT BLOWER MOTOR INSPECTION [FULL-AUTO AIR CONDITIONER] FRONT POWER METAL OXI DE SEMI CONDUCTOR FI ELD EFFECT TRANSI STOR (POWER MOS FET) REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] FRONT POWER METAL OXI DE SEMI CONDUCTOR FI ELD EFFECT TRANSI STOR (POWER MOS FET) INSPECTION [FULL-AUTO AIR CONDITIONER] MAGNETIC CLUTCH DISASSEMBLY/ASSEMBLY [FULL-AUTO AIR CONDITIONER] MAGNETIC CLUTCH ADJUSTMENT [FULL-AUTO AIR CONDITIONER] MAGNETIC CLUTCH INSPECTION [FULL-AUTO AIR CONDITIONER] SOLAR RADI ATI ON SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] SOLAR RADI ATI ON SENSOR INSPECTION [FULL-AUTO AIR CONDITIONER] AMBI ENT TEMPERATURE SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] AMBI ENT TEMPERATURE SENSOR INSPECTION [FULL-AUTO AIR CONDITIONER] PASSENGER COMPARTMENT TEMPERATURE SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] PASSENGER COMPARTMENT TEMPERATURE SENSOR INSPECTION [FULL-AUTO AIR CONDITIONER] EVAPORATOR TEMPERATURE SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] EVAPORATOR TEMPERATURE SENSOR INSPECTION [FULL-AUTO AIR CONDITIONER] REFRIGERANT PRESSURE SENSOR REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] REFRIGERANT PRESSURE SENSOR INSPECTION [FULL-AUTO AIR CONDITIONER] CLIMATE CONTROL UNIT REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] CLIMATE CONTROL UNIT INSPECTION [FULL-AUTO AIR CONDITIONER]

CONTROL SYSTEM

HVAC CONTROL SYSTEM LOCATION INDEX [MANUAL AIR CONDITIONER] AIR INTAKE ACTUATOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] AIR INTAKE ACTUATOR INSPECTION [MANUAL AIR CONDITIONER] AIR MIX ACTUATOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] AIR MIX ACTUATOR INSPECTION [MANUAL AIR CONDITIONER] AI RFLOW MODE ACTUATOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] AI RFLOW MODE ACTUATOR INSPECTION [MANUAL AIR CONDITIONER] BLOWER MOTOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] BLOWER MOTOR INSPECTION [MANUAL AIR CONDITIONER] RESI STOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] RESI STOR INSPECTION [MANUAL AIR CONDITIONER] MAGNETIC CLUTCH DISASSEMBLY/ASSEMBLY [MANUAL AIR CONDITIONER] MAGNETIC CLUTCH ADJUSTMENT [MANUAL AIR CONDITIONER] MAGNETIC CLUTCH INSPECTION [MANUAL AIR CONDITIONER] AMBI ENT TEMPERATURE SENSOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] AMBI ENT TEMPERATURE SENSOR INSPECTION [MANUAL AIR CONDITIONER] EVAPORATOR TEMPERATURE SENSOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] EVAPORATOR TEMPERATURE SENSOR INSPECTION [MANUAL AIR CONDITIONER] REFRIGERANT PRESSURE SENSOR REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] REFRIGERANT PRESSURE SENSOR INSPECTION [MANUAL AIR CONDITIONER] CLIMATE CONTROL UNIT REMOVAL/INSTALLATION [MANUAL AIR CONDITIONER] CLIMATE CONTROL UNIT INSPECTION [MANUAL AIR CONDITIONER]

TECHNICAL DATA

HVAC TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

HVAC SST

Workshop MANUAL-RESTRAINTS

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM FOREWORD FLOW CHART DTC INSPECTION CLEARING DTC DTC TABLE DTC B0 00 1: 11/B0 00 1: 12/B0 00 1: 13/B0 00 1: 19/B0 00 1: 1A DTC B0 00 1: 55/B0 01 0: 55 DTC B0 00 2: 11/B0 00 2: 12/B0 00 2: 13/B0 00 2: 19/B0 00 2: 1A DTC B0 00 2: 55/B0 01 1: 55 DTC B0 00 3: 53 DTC B0 01 0: 11/B0 01 0: 12/B0 01 0: 13/B0 01 0: 19/B0 01 0: 1A DTC B0 01 1: 11/B0 01 1: 12/B0 01 1: 13/B0 01 1: 19/B0 01 1: 1A DTC B0 07 0: 11/B0 07 0: 12/B0 07 0: 13/B0 07 0: 19/B0 07 0: 1A DTC B0 07 0: 55/B0 07 2: 55 DTC B0 07 2: 11/B0 07 2: 12/B0 07 2: 13/B0 07 2: 19/B0 07 2: 1A DTC B0 09 4: 11/B0 09 4: 13/B0 09 4: 87/B0 09 4: 96 DTC B0 09 4: 55 DTC B00A0: 09 DTC B00A0: 28 DTC B00A0: 4A DTC B00A0: 54 DTC B00A0: 81/B00A0: 87/B00A0: 8F DTC B00B5: 11/B00B5: 12/B00B5: 13/B00B5: 1D DTC B00B5: 55 DTC B0 0 C1: 93 DTC B0 0 C2: 93 DTC B0 0 D2: 01 DTC B0 0 D2: 29 DTC B0 0 D5: 11/B0 0 D5: 12/B0 0 D5: 13 DTC B0 0 D5: 55 DTC B1 01 1: 95 DTC B1 0 FD: 11/B1 0 FD: 13/B1 0 FD: 87/B1 0 FD: 96 DTC B1 0 FD: 55/B1 0 FE: 55 DTC B1 0 FE: 11/B1 0 FE: 13/B1 0 FE: 87/B1 0 FE: 96 DTC B1 12 6: 11/B1 12 6: 12/B1 12 6: 13/B1 12 6: 19/B1 12 6: 1A DTC B1 12 6: 55/B1 12 7: 55 DTC B1 12 7: 11/B1 12 7: 12/B1 12 7: 13/B1 12 7: 19/B1 12 7: 1A DTC B1 12 8: 11/B1 12 8: 12/B1 12 8: 13/B1 12 8: 19/B1 12 8: 1A DTC B1 12 8: 55/B1 12 9: 55 DTC B1 12 9: 11/B1 12 9: 12/B1 12 9: 13/B1 12 9: 19/B1 12 9: 1A DTC B1 19 3: 00 DTC B1 19 6: 11/B1 19 6: 13/B1 19 6: 87/B1 19 6: 96 DTC B1 19 6: 55/B1 19 7: 55 DTC B1 19 7: 11/B1 19 7: 13/B1 19 7: 87/B1 19 7: 96 DTC B1 D7 5: 55 DTC B1 22 6: 11/B1 22 6: 13/B1 22 6: 87/B1 22 6: 96 DTC B1 22 6: 55 , B1 22 7: 55 DTC B1 22 7: 11/B1 22 7: 13/B1 22 7: 87/B1 22 7: 96 DTC C0 06 1: 29/C0 06 2: 29/C0 06 3: 29 DTC U0 02 8: 88 DTC U0 30 0: 00/U2 10 0: 00 DTC U3 00 0: 46/U3 00 0: 49 DTC U3003: 16/U3003: 17 PID/DATA MONI TOR INSPECTION PID/DATA MONI TOR TABLE

SYMPTOM TROUBLESHOOTING

AIRBAG SYSTEM WIRING DIAGRAM (SYMPTOM TROUBLESHOOTING) TROUBLESHOOTING INDEX NO.1 AIRBAG SYSTEM WARNING LIGHT DOES NOT ILLUMINATE NO.2 AIRBAG SYSTEM WARNING LIGHT ILLUMINATES CONSTANTLY

AIRBAG SYSTEM

AIRBAG SYSTEM LOCATION INDEX AIRBAG SYSTEM SERVICE WARNINGS AIRBAG SYSTEM SERVICE CAUTIONS DRIVER-SIDE AIRBAG MODULE REMOVAL/INSTALLATION PASSENGER-SIDE AIRBAG MODULE REMOVAL/INSTALLATION SIDE AIRBAG MODULE REMOVAL/INSTALLATION CURTAIN AIRBAG MODULE REMOVAL/INSTALLATION CRASH ZONE SENSOR REMOVAL/INSTALLATION SAS CONTROL MODULE REMOVAL/INSTALLATION SAS CONTROL MODULE CONFIGURATION SEAT TRACK POSITION SENSOR REMOVAL/INSTALLATION SEAT WEIGHT SENSOR CONTROL MODULE REMOVAL/INSTALLATION SEAT WEIGHT SENSOR CALIBRATION SEAT WEIGHT SENSOR INSPECTION SIDE AIRBAG SENSOR NO. 1 REMOVAL/INSTALLATION SIDE AIRBAG SENSOR NO. 2 REMOVAL/INSTALLATION PRESSURE SENSOR REMOVAL/INSTALLATION CLOCK SPRING REMOVAL/INSTALLATION CLOCK SPRING ADJUSTMENT CLOCK SPRING INSPECTION PASSENGER AIRBAG DEACTIVATION (PAD) INDICATOR LIGHT BULB REMOVAL/INSTALLATION AIRBAG MODULE AND PRE-TENSIONER SEAT BELT DEPLOYMENT PROCEDURES AIRBAG MODULE AND PRE-TENSIONER SEAT BELT DISPOSAL PROCEDURES INSPECTION OF SST (DEPLOYMENT TOOL)

SEAT BELT

SEAT BELT LOCATION INDEX FRONT SEAT BELT REMOVAL/INSTALLATION ADJUSTER ANCHOR REMOVAL/INSTALLATION REAR SEAT BELT REMOVAL/INSTALLATION REAR CENTER SEAT BELT REMOVAL/INSTALLATION SEAT BELT INSPECTION FRONT BUCKLE REMOVAL/INSTALLATION REAR BUCKLE REMOVAL/INSTALLATION BUCKLE SWITCH INSPECTION CHI LD-RESTRAINT SEAT ANCHOR REMOVAL/INSTALLATION

MAINTENANCE/SERVICE TOOLS

RESTRAINTS SST

Workshop MANUAL-Body and Accessories

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] FOREWORD [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] CLEARING DTC [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC TABLE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 00 B: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 00 B: 15 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 00 C: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 00 C: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 08 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 51 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 62 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 71 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 87 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 92 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 6: 96 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 02 B: 51 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 08 B: 23 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 08 B: 29 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 08 C: 23 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 A5: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 C1: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 C1: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 C3: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 C3: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B10C6: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B10C7: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B10C8: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B10C9: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 D1: 23 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 D3: 23 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 E7: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 E7: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 E7: 16 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 0 E7: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 12 A: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 12 A: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 12 A: 16 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 12 A: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 13 E: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B11FD: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1210: 1F [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 1 E8: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC B1 1 E8: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC C0 04 0: 29 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 56 0: 16 , P0 56 0: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 61 5: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 61 5: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 61 5: 13 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 81 C: 62 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 81 D: 62 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 83 0: 23 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P0 85 0: 29 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P1 70 8: 29 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC P1 79 4: 16 , P1 79 4: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U0 02 8: 87 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U0 40 1: 68 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U2 01 F: 00 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U2 01 F: 13 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U2 10 0: 00 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 0: 41 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 0: 49 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3003: 16 , U3003: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 4: 11 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 4: 12 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 4: 16 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] DTC U3 00 4: 17 [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] PID/DATA MONI TOR INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] PID/DATA MONI TOR TABLE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] ACTIVE COMMAND MODES INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] ACTIVE COMMAND MODES TABLE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM]

ON-BOARD DIAGNOSTICS

FOREWORD [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] DTC INSPECTION [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] CLEARING DTC [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] DTC TABLE [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 11 , DTC: B1 0 D9: 87/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 12 , DTC: B1 0 D5: 13/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 13 , DTC: B1 0 D7: 05/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 13 , DTC: B1 0 D7: 94/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 14 , DTC: B1 0 D7: 81/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 15 , DTC: B1 0 D7: 51/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 16 , DTC: U0 10 0: 87/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 21 , DTC: B1 0 D8: 00/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 22 , DTC: B1 0 DA: 51/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: 23 , DTC: B1 0 DA: 62/P1 26 0: 00 [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: NOT I LLUMI NATED, DTC B1 0 E6: 11/- [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] SECURITY LIGHT: NOT I LLUMI NATED, DTC B1 0 E6: 12/- [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] PID/DATA MONI TOR INSPECTION [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)] PID/DATA MONI TOR TABLE [IMMOBILIZER SYSTEM (ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM)]

ON-BOARD DIAGNOSTICS

FOREWORD [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] DTC INSPECTION [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] CLEARING DTC [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] DTC TABLE [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 11 , DTC: B1 0 D9: 87/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 12 , DTC: B1 0 D5: 13/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 13 , DTC: B1 0 D7: 05/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 13 , DTC: B1 0 D7: 94/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 14 , DTC: B1 0 D7: 81/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 15 , DTC: B1 0 D7: 51/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 16 , DTC: U0 10 0: 87/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 21 , DTC: B1 0 D8: 00/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 22 , DTC: B1 0 DA: 51/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] SECURITY LIGHT: 23 , DTC: B1 0 DA: 62/P1 26 0: 00 [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] PID/DATA MONI TOR INSPECTION [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)] PID/DATA MONI TOR TABLE [IMMOBILIZER SYSTEM (KEYLESS ENTRY SYSTEM)]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [AUTO LIGHT/WIPER CONTROL MODULE] DTC INSPECTION [AUTO LIGHT/WIPER CONTROL MODULE] CLEARING DTC [AUTO LIGHT/WIPER CONTROL MODULE] DTC TABLE [AUTO LIGHT/WIPER CONTROL MODULE] DTC B1 01 4 [AUTO LIGHT/WIPER CONTROL MODULE] DTC B1 31 7 [AUTO LIGHT/WIPER CONTROL MODULE] DTC B1 31 8 [AUTO LIGHT/WIPER CONTROL MODULE] DTC B1 34 2 [AUTO LIGHT/WIPER CONTROL MODULE] DTC U2 03 0 [AUTO LIGHT/WIPER CONTROL MODULE]

ON-BOARD DIAGNOSTICS

FOREWORD [AUDIO] DTC INSPECTION [AUDIO] SUPPLI ER IDENTIFICATION PROCEDURE [AUDIO] CLEARING DTC [AUDIO] DTC TABLE [AUDIO] DTC: DEVICE CORD 15/ERROR CORD 19 [AUDIO] DTC: 10: Er0 7 , 22: Er0 7 , DEVICE CORD 22/ERROR CORD 07 [AUDIO] DTC: 10: ER0 2 , 22: Er0 2 , DEVICE CORD 22/ERROR CORD 02 [AUDIO] DTC: 10: Er0 1 , 22: Er0 1 , DEVICE CORD 22/ERROR CORD 01 [AUDIO] DTC: DEVICE CORD 22/ERROR CORD 10 [AUDIO] DTC: 10: Er0 9 , 22: Er0 9 , DEVICE CORD 22/ERROR CORD 09 [AUDIO] DTC: 09: Er2 1 , DEVICE CORD 09/ERROR CORD 21 [AUDIO] DTC: 09: Er2 0 , DEVICE CORD 09/ERROR CORD 20 [AUDIO] DIAGNOSTIC ASSIST FUNCTION [AUDIO]

ON-BOARD DIAGNOSTICS

FOREWORD [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC INSPECTION [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] CLEARING DTC [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC TABLE [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC: 26: Er8 5 , DEVICE CORD 26/ERROR CORD 85 [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC: 26: Er8 2 , DEVICE CORD 26/ERROR CORD 82 [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC: 26: Er8 4 , DEVICE CORD 26/ERROR CORD 84 [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC: 26: Er8 3 , DEVICE CORD 26/ERROR CORD 83 [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DTC: 26: Er8 6 , DEVICE CORD 26/ERROR CORD 86 [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] DIAGNOSTIC ASSIST FUNCTION [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)]

ON-BOARD DIAGNOSTICS

STARTI NG PROCEDURE FOR ON-BOARD DIAGNOSTIC TEST MODE [CAR-NAVIGATION SYSTEM] SUPPLI ER IDENTIFICATION PROCEDURE [CAR-NAVIGATION SYSTEM] CLEARING DTC [CAR-NAVIGATION SYSTEM] DTC TABLE [CAR-NAVIGATION SYSTEM] DIAGNOSTIC ASSIST FUNCTION [CAR-NAVIGATION SYSTEM] STARTI NG PROCEDURE FOR DIAGNOSTIC MODE [CAR-NAVIGATION SYSTEM] DIAGNOSTIC CHECK [CAR-NAVIGATION SYSTEM] NAVIGATION CHECK [CAR-NAVIGATION SYSTEM]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [INSTRUMENT CLUSTER] DTC INSPECTION [INSTRUMENT CLUSTER] CLEARING DTC [INSTRUMENT CLUSTER] DTC TABLE [INSTRUMENT CLUSTER] DTC P0 07 0: 14 [INSTRUMENT CLUSTER] DTC U0 30 0: 00 [INSTRUMENT CLUSTER] DTC U0 40 1: 68 [INSTRUMENT CLUSTER] DTC U0 40 1: 92 [INSTRUMENT CLUSTER] DTC U0 40 2: 68 [INSTRUMENT CLUSTER] DTC U0 40 2: 92 [INSTRUMENT CLUSTER] DTC U0 41 5: 68 [INSTRUMENT CLUSTER] DTC U0 41 5: 92 [INSTRUMENT CLUSTER] DTC U0 45 2: 92 [INSTRUMENT CLUSTER] DTC U0 51 5: 68 [INSTRUMENT CLUSTER] DTC U0 51 5: 92 [INSTRUMENT CLUSTER] DTC U0 53 3: 68 [INSTRUMENT CLUSTER] DTC U2 00 5: 86 [INSTRUMENT CLUSTER] DTC U2 10 0: 00 [INSTRUMENT CLUSTER] DTC U3 00 0: 41 [INSTRUMENT CLUSTER] DTC U3003: 16 [INSTRUMENT CLUSTER] PID/DATA MONI TOR INSPECTION [INSTRUMENT CLUSTER] PID/DATA MONI TOR TABLE [INSTRUMENT CLUSTER] ACTIVE COMMAND MODES INSPECTION [INSTRUMENT CLUSTER] ACTIVE COMMAND MODES TABLE [INSTRUMENT CLUSTER]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [BLIND SPOT MONITORING (BSM)] DTC INSPECTION [BLIND SPOT MONITORING (BSM)] CLEARING DTC [BLIND SPOT MONITORING (BSM)] DTC TABLE [BLIND SPOT MONITORING (BSM)] DTC B1 18 C: 11 [BLIND SPOT MONITORING (BSM)] DTC B1 18 C: 15 [BLIND SPOT MONITORING (BSM)] DTC B1 18 D: 11 [BLIND SPOT MONITORING (BSM)] DTC B1 18 D: 15 [BLIND SPOT MONITORING (BSM)] DTC U0 40 1: 68 [BLIND SPOT MONITORING (BSM)] DTC U0 40 2: 68 [BLIND SPOT MONITORING (BSM)] DTC U0 42 2: 68 [BLIND SPOT MONITORING (BSM)] DTC U0 53 3: 68 [BLIND SPOT MONITORING (BSM)] DTC U0 53 4: 68 [BLIND SPOT MONITORING (BSM)] DTC U3 00 0: 01 [BLIND SPOT MONITORING (BSM)] DTC U3 00 0: 09 [BLIND SPOT MONITORING (BSM)] DTC U3 00 0: 4A [BLIND SPOT MONITORING (BSM)] DTC U3 00 0: 97 [BLIND SPOT MONITORING (BSM)] DTC U3003: 16/U3003: 17 [BLIND SPOT MONITORING (BSM)] PID/DATA MONI TOR INSPECTION [BLIND SPOT MONITORING (BSM)] PID/DATA MONI TOR TABLE [BLIND SPOT MONITORING (BSM)] ACTIVE COMMAND MODES INSPECTION [BLIND SPOT MONITORING (BSM)] ACTIVE COMMAND MODES TABLE [BLIND SPOT MONITORING (BSM)]

ON-BOARD DIAGNOSTICS

ON-BOARD DIAGNOSTIC WIRING DIAGRAM [BCM] DTC INSPECTION [BCM] CLEARING DTC [BCM] DTC TABLE [BCM] DTC B1 D3 5: 11 [BCM] DTC B1 D3 6: 11 [BCM] DTC B1 0 D0: 11 [BCM] DTC B1 04 8: 11 [BCM] DTC B1 07 9: 13 [BCM] DTC B1 08 F: 16 [BCM] DTC B1 1 C0: 13 [BCM] DTC B1 1 C1: 13 [BCM] DTC B1 1 DA: 11 [BCM] DTC B1 13 E: 11 [BCM] DTC B1 17 2: 11 [BCM] DTC B1 17 2: 13 [BCM] DTC B1 17 4: 11 [BCM] DTC B1 17 4: 13 [BCM] DTC B1 17 5: 13 [BCM] DTC B1 17 6: 13 [BCM] DTC B1 17 8: 11 [BCM] DTC B1 26 A: 11 [BCM] DTC B1 26 A: 13 [BCM] DTC C0 05 1: 04 [BCM] DTC C0 05 1: 2F/C0 05 2: 11/C0 05 2: 13/C0 05 3: 11/C0 05 3: 13/C0 05 4: 11/C0 05 4: 13/C0 05 5: 11/C0 05 5: 13 [BCM] DTC C1 13 7: 12 [BCM] DTC P1 53 6: 13 [BCM] DTC U0 30 0: 00 [BCM] DTC U0 40 1: 68 [BCM] DTC U0 40 2: 68 [BCM] DTC U2 10 0: 00 [BCM] DTC U3 00 0: 04 [BCM] DTC U3003: 16/U3003: 17 [BCM] PID/DATA MONI TOR INSPECTION [BCM] PID/DATA MONI TOR TABLE [BCM]

ON-BOARD DIAGNOSTICS

FOREWORD [MULTIPLEX COMMUNICATION SYSTEM] DTC TABLE [MULTIPLEX COMMUNICATION SYSTEM] DETERMI NI NG MALFUNCTIONING PART (HS-CAN) [MULTIPLEX COMMUNICATION SYSTEM] DETERMI NI NG MALFUNCTIONING PART (MS-CAN) [MULTIPLEX COMMUNICATION SYSTEM] M-MDS AND VEHICLE NOT COMMUNI CATI NG [MULTIPLEX COMMUNICATION SYSTEM] DTC U0 00 1: 88 , U0 07 3: 00 [MULTIPLEX COMMUNICATION SYSTEM] DTC U0 01 0: 88 , 01: Er, 16: Er1 1 , 16: Er1 2 , 26: Er8 1 [MULTIPLEX COMMUNICATION SYSTEM]

SYMPTOM TROUBLESHOOTING

AUTO DOOR LOCK SYSTEM WIRING DIAGRAM [AUTO DOOR LOCK SYSTEM] SYMPTOM TROUBLESHOOTING CHART [AUTO DOOR LOCK SYSTEM] No.1 AUTO DOOR LOCK FUNCTION DOES NOT OPERATE [AUTO DOOR LOCK SYSTEM] No.2 AUTO DOOR UNLOCK FUNCTION DOES NOT OPERATE [AUTO DOOR LOCK SYSTEM]

SYMPTOM TROUBLESHOOTING

POWER WINDOW SYSTEM WIRING DIAGRAM [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] FOREWORD [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] SYMPTOM TROUBLESHOOTING CHART [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] POWER WINDOW SYSTEM TROUBLESHOOTING QUESTI ONNAI RE [POWER WINDOW SYSTEMS (AUTO- OPEN/CLOSE FUNCTION)] INTERMITTENT CONCERN TROUBLESHOOTING [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] BASIC POWER WINDOW SYSTEM INSPECTION [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] No.1 DOOR GLASS DOES NOT MOVE UP AND DOWN IN AUTOMATIC MODE [POWER WINDOW SYSTEMS (AUTO- OPEN/CLOSE FUNCTION)] No.2 DOOR GLASS DOES NOT REVERSE, EVEN WHEN ENCOUNTERING A FOREIGN OBJECT IN ITS PATH [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] No.3 DOOR GLASS REVERSES EVEN THOUGH THE GLASS DOES NOT ENCOUNTER A FOREIGN OBJECT WHILE IT IS MOVING UP IN AUTOMATIC MODE [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)] No.4 ABNORMAL NOISE WHILE THE DOOR GLASS IS OPENI NG OR CLOSI NG [POWER WINDOW SYSTEMS (AUTO-OPEN/CLOSE FUNCTION)]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING CHART [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] QUICK DIAGNOSTIC CHART [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.1 DOOR GLASS DOES NOT OPERATE EVEN THOUGH VARI OUS OPERATI ONS ARE PERFORMED [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.2 DOOR GLASS DOES NOT OPERATE USING THE KEYLESS TRANSMITTER [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.3 DOOR GLASS DOES NOT OPERATE USING THE REQUEST SWITCH [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.4 PASSENGER DOOR GLASS DOES NOT OPERATE [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.5 DOOR GLASS STOPS BEFORE FULLY OPENI NG/CLOSI NG [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.6 DRIVER'S AND PASSENGER'S DOOR GLASSES OPERATE ACCI DENTALLY [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)] No.7 PASSENGER'S DOOR GLASS OPERATES ACCI DENTALLY [POWER WINDOW SYSTEM (EXTERIOR OPEN FUNCTION)]

SYMPTOM TROUBLESHOOTING

POWER WINDOW SYSTEM WIRING DIAGRAM [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] FOREWORD [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] SYMPTOM TROUBLESHOOTING CHART [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] POWER WINDOW SYSTEM TROUBLESHOOTING QUESTI ONNAI RE [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] POWER WINDOW SYSTEM PRELI MI NARY INSPECTION [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.1 THE AUTO OPEN/CLOSE FUNCTION ON THE DRIVER'S SIDE POWER WINDOW IS INOPERATIVE [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.2 THE DRIVER'S SIDE POWER WINDOW IS INOPERATIVE [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.3 ALL POWER WINDOWS OTHER THAN DRIVER'S SIDE DO NOT OPERATE USING THE POWER WINDOW SUBSW I TCH [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.4 ALL POWER WINDOWS OTHER THAN DRIVER'S SIDE DO NOT OPERATE USING THE POWER WINDOW MAIN SWITCH [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.5 ALL POWER WINDOWS ARE INOPERATIVE [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.6 DOOR GLASS REVERSES EVEN THOUGH THE GLASS DOES NOT ENCOUNTER A FOREIGN OBJECT WHILE IT IS MOVING UP IN AUTOMATIC MODE [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)] No.7 ABNORMAL NOISE WHILE THE DOOR GLASS IS OPENI NG OR CLOSI NG [POWER WINDOW SYSTEMS (WITHOUT EXTERIOR OPEN FUNCTION)]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING CHART [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS ENTRY SYSTEM WIRING DIAGRAM [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] TROUBLESHOOTING INDEX [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS ENTRY SYSTEM CHECK SHEET [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] NO.1 DOOR CANNOT BE LOCKED/UNLOCKED BY ADVANCED KEY [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] NO.2 ADVANCED KEYLESS ENTRY FUNCTION INOPERATIVE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] NO.3 PUSH BUTTON START SYSTEM DOES NOT OPERATE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] NO.4 AFTER ENGINE START, ELECTRI CAL DEVI CES DO NOT OPERATE [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] NO.5 PUSH BUTTON START SYSTEM DOES NOT TURN OFF (IG OFF) [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING CHART [KEYLESS ENTRY SYSTEM] KEYLESS ENTRY SYSTEM WIRING DIAGRAM [KEYLESS ENTRY SYSTEM] TROUBLESHOOTING INDEX [KEYLESS ENTRY SYSTEM] KEYLESS ENTRY SYSTEM CHECK SHEET [KEYLESS ENTRY SYSTEM] KEYLESS ENTRY SYSTEM OPERATION INSPECTION [KEYLESS ENTRY SYSTEM] KEYLESS ENTRY SYSTEM PRELI MI NARY INSPECTION [KEYLESS ENTRY SYSTEM] NO.1 KEYLESS ENTRY SYSTEM DOES NOT OPERATE NORMALLY [KEYLESS ENTRY SYSTEM] NO.2 ALL KEYLESS ENTRY SYSTEM FUNCTI ONS INOPERATIVE [KEYLESS ENTRY SYSTEM] NO.3 TRANSMITTER ID CODE CANNOT BE REPROGRAMMED [KEYLESS ENTRY SYSTEM]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING CHART [IMMOBILIZER SYSTEM] NO.1 SECURITY LIGHT DISPLAY IS NOT NORMAL [IMMOBILIZER SYSTEM]

SYMPTOM TROUBLESHOOTING

FOREWORD [ENTIRE AUDIO SYSTEM] CONFIRMATION STEP 1: AUDIO PANEL SWITCH CONFIRMATION [ENTIRE AUDIO SYSTEM] CONFIRMATION STEP 2: STEERING SWITCH CONFIRMATION [ENTIRE AUDIO SYSTEM] AUDIO UNIT RESET PROCEDURE [ENTIRE AUDIO SYSTEM] NO.1 AF NOISE OR POP NOISE AT ALL SOURCES (RADIO, CD) [ENTIRE AUDIO SYSTEM] NO.2 AUDIO POWER IS NOT AVAI LABLE OR SW I TCHED ON OR OFF AUTOMATI CALLY [ENTIRE AUDIO SYSTEM] NO.3 NO SOUND FROM ALL SPEAKERS [ENTIRE AUDIO SYSTEM] NO.4 NO SOUND FROM SOME SPEAKERS [ENTIRE AUDIO SYSTEM] NO.5 SOUND BREAK-UP OR POOR SOUND QUALI TY [ENTIRE AUDIO SYSTEM] NO.6 VOLUME I NCREASES/DECREASES WHILE DRI VI NG THE VEHICLE [ENTIRE AUDIO SYSTEM] NO.7 ALC FUNCTION IS INOPERATIVE [ENTIRE AUDIO SYSTEM] NO.8 AudioPilot® 2 FUNCTION IS INOPERATIVE [ENTIRE AUDIO SYSTEM] NO.9 NO AUDIO SYSTEM ILLUMINATION [ENTIRE AUDIO SYSTEM] NO.10 LCD DOES NOT DISPLAY AT ALL [ENTIRE AUDIO SYSTEM] NO.11 DISPLAY DOES NOT CHANGE TO THE REAR MOUNT CAMERA I MAGE [ENTIRE AUDIO SYSTEM] NO.12 SOUND JUMPS [ENTIRE AUDIO SYSTEM]

SYMPTOM TROUBLESHOOTING

FOREWORD [RADIO] CONFIRMATION STEP 1: RECEPTION CONDI TI ON SYMPTOM (EXAMPLE) [RADIO] CONFIRMATION STEP 2: ANTENNA SYSTEM SYMPTOM (EXAMPLE) [RADIO] CONFIRMATION STEP 3: ANTENNA SYSTEM SI MPLE INSPECTION [RADIO] NO.1 NO RADIO RECEPTION (AM/FM)/NO OR LOW VOLUME [RADIO] NO.2 NO RADIO RECEPTION (SIRIUS SATELLITE RADIO) [RADIO] NO.3 NOISE FROM RADIO (AM ONLY) [RADIO] NO.4 NOISE FROM RADIO (FM ONLY) [RADIO] NO.5 NOISE FROM RADIO (SIRIUS SATELLITE RADIO ONLY) [RADIO] NO.6 CANNOT TUNE (SEEK DOES NOT STOP) [RADIO] NO.7 CANNOT PRESET (PRESET FUNCTION DOES NOT OPERATE) [RADIO] NO.8 RECEPTION FREQUENCY OF RADIO SLIPS [RADIO] REFERENCE [RADIO]

SYMPTOM TROUBLESHOOTING

FOREWORD [CD PLAYER/CHANGER] NO.1 CD PLAYER/CHANGER DOES NOT LOAD THE CD OR EJECTS THE CD I MMEDI ATELY [CD PLAYER/CHANGER] NO.2 CD PLAYER/CHANGER DOES NOT EJECT THE CD [CD PLAYER/CHANGER] NO.3 CD PLAYER/CHANGER DOES NOT PLAY THE CD/NO SOUND [CD PLAYER/CHANGER] NO.4 SOUND JUMPS [CD PLAYER/CHANGER] NO.5 CD PLAYER/CHANGER SCRATCHES ON THE CD [CD PLAYER/CHANGER] NO.6 DISC CHANGE IS INOPERATIVE [CD PLAYER/CHANGER] NO.7 CD PLAYER DOES NOT PLAY THE MP3/WMA-FORMATTED [CD PLAYER/CHANGER] NO.8 MP3/WMA-FORMATTED FILE FOLDER SELECTION IS INOPERATIVE/TRACK SEARCH IS INOPERATIVE [CD PLAYER/CHANGER] NO.9 CD PLAYER DOES NOT I NDI CATE THE MP3/WMA TI TLE TEXT [CD PLAYER/CHANGER] NO.10 CD PLAYER DOES NOT PLAY THE AUDIO DATA (CDDA) [CD PLAYER/CHANGER] NO.11 TRACK CHANGE IS INOPERATIVE [CD PLAYER/CHANGER] REFERENCE [CD PLAYER/CHANGER]

SYMPTOM TROUBLESHOOTING

FOREWORD [CAR-NAVIGATION SYSTEM] NO.1 CAR-NAVIGATION SYSTEM DOES NOT START OPERATION (DISPLAY CHANGES TO BACK.) [CAR- NAVIGATION SYSTEM] NO.2 SYSTEM DOES NOT CONTROL AUDIO BY STEERING SWITCH [CAR-NAVIGATION SYSTEM] NO.3 SYSTEM DOES NOT LOAD MAP DISC. [CAR-NAVIGATION SYSTEM] NO.4 NO SOUND FROM AUDIO SYSTEM [CAR-NAVIGATION SYSTEM] NO.5 VEHICLE POSITION DEVI ATES FROM THE ROUTE MAP [CAR-NAVIGATION SYSTEM] NO.6 NO VOI CE NAVIGATION [CAR-NAVIGATION SYSTEM] NO.7 DISPLAY SCREEN DOES NOT CHANGE TO THE NI GHT MODE (FRONT AND REAR COMBINATION LIGHTS OPERATE NORMALLY.) [CAR-NAVIGATION SYSTEM] NO.8 SPEECH RECOGNI TI ON DOES NOT START [CAR-NAVIGATION SYSTEM] NO.9 DISPLAY DOES NOT CHANGE TO THE REAR MOUNT CAMERA I MAGE [CAR-NAVIGATION SYSTEM] SELF-DIAGNOSTIC [CAR-NAVIGATION SYSTEM]

SYMPTOM TROUBLESHOOTING

FOREWORD [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] No.1 HANDS-FREE TELEPHONE SYSTEM DOES NOT RECEIVE/TRANSMIT CALLS, DOES NOT CONNECT [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] No.2 CALLER'S VOI CE VOLUME TOO LOW , OR NOISE I NTERRUPTS CALL [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)] No.3 ADDRESSEE'S VOI CE VOLUME TOO LOW , OR NOISE I NTERRUPTS CALL [Bluetooth SYSTEM (HANDS-FREE TELEPHONE (HF/TEL) SYSTEM)]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] QUICK DIAGNOSTIC CHART [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 1 FUEL GAUGE NEEDLE POSITION I NCORRECT [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 2 ALL METERS AND GAUGES DO NOT OPERATE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 3 ABS WARNING LIGHT ILLUMINATES [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 4 MIL ILLUMINATES [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 5 BRAKE SYSTEM WARNING LIGHT ILLUMINATES [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 6 INSTRUMENT CLUSTER ILLUMINATION DOES NOT ILLUMINATE WHEN TAILLIGHTS ILLUMINATE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 7 INSTRUMENT CLUSTER ILLUMINATION DOES NOT DIM WHEN TAILLIGHTS ILLUMINATE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 8 SPEEDOMETER INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 9 TACHOMETER INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)] NO. 10 WATER TEMPERATURE GAUGE INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITHOUT MALFUNCTION WARNING LIGHT)]

SYMPTOM TROUBLESHOOTING

SYMPTOM TROUBLESHOOTING [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] QUICK DIAGNOSTIC CHART [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 1 FUEL GAUGE NEEDLE POSITION I NCORRECT [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 2 ALL METERS AND GAUGES DO NOT OPERATE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 3 ABS WARNING LIGHT ILLUMINATES [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 4 MIL ILLUMINATES [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 5 BRAKE SYSTEM WARNING LIGHT ILLUMINATES [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 6 INSTRUMENT CLUSTER ILLUMINATION DOES NOT ILLUMINATE WHEN TAILLIGHTS ILLUMINATE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 7 INSTRUMENT CLUSTER ILLUMINATION DOES NOT DIM WHEN TAILLIGHTS ILLUMINATE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 8 SPEEDOMETER INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 9 TACHOMETER INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 10 WATER TEMPERATURE GAUGE INDICATION IS DEFECTIVE [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)] NO. 11 MALFUNCTION WARNING LIGHT ILLUMINATES [INSTRUMENT CLUSTER (WITH MALFUNCTION WARNING LIGHT)]

SYMPTOM TROUBLESHOOTING

TROUBLESHOOTING INDEX [BLIND SPOT MONITORING (BSM)] BLIND SPOT MONITORING (BSM) WIRING DIAGRAM [BLIND SPOT MONITORING (BSM)] FOREWORD [BLIND SPOT MONITORING (BSM)] NO.1 BSM OFF INDICATOR LIGHT DOES NOT ILLUMINATE WHEN THE IGNITION IS SW I TCHED TO ON [BLIND SPOT MONITORING (BSM)] NO.2 BSM OFF INDICATOR LIGHT DOES NOT ILLUMINATE WHILE BSM SYSTEM IS OFF [BLIND SPOT MONITORING (BSM)] NO.3 BSM OFF INDICATOR LIGHT ILLUMINATES CONTINUOUSLY [BLIND SPOT MONITORING (BSM)] NO.4 BSM INDICATOR LIGHT ILLUMINATES WHILE NOT UNDER LIGHT-ILLUMINATION CONDITIONS [BLIND SPOT MONITORING (BSM)] NO.5 BSM INDICATOR LIGHT DOES NOT ILLUMINATE WHILE UNDER BSM INDICATOR LIGHT-ILLUMINATION CONDITIONS [BLIND SPOT MONITORING (BSM)] NO.6 BSM INDICATOR LIGHT FLASHES WHILE NOT UNDER BSM INDICATOR LIGHT-FLASHI NG CONDITIONS (NO COMBINATION SWITCH OPERATION (TURN SI GNAL SWITCH)) [BLIND SPOT MONITORING (BSM)] NO.7 BSM INDICATOR LIGHT DOES NOT FLASH WHILE UNDER BSM INDICATOR LIGHT-FLASHI NG CONDITIONS (WITH COMBINATION SWITCH OPERATION (TURN SI GNAL SWITCH)) [BLIND SPOT MONITORING (BSM)] NO.8 THE BSM INDICATOR LIGHT DOES NOT FLASH OR ILLUMINATE CONTINUOUSLY, BUT A TURN SI GNAL IS ON [BLIND SPOT MONITORING (BSM)] NO.9 BSM WARNING ALARM DOES NOT SOUND WHILE BSM INDICATOR LIGHT FLASHES [BLIND SPOT MONITORING (BSM)]

BODY PANELS

BODY PANELS LOCATION INDEX TRUNK LID REMOVAL/INSTALLATION TRUNK LID ADJUSTMENT TRUNK LID STAY DAMPER DISPOSAL FUEL-FILLER LID REMOVAL/INSTALLATION FUEL-FILLER LID ADJUSTMENT HOOD REMOVAL/INSTALLATION HOOD DISASSEMBLY/ASSEMBLY HOOD ADJUSTMENT FRONT BUMPER REMOVAL/INSTALLATION FRONT BUMPER DISASSEMBLY/ASSEMBLY FRONT BUMPER REI NFORCEMENT REMOVAL/INSTALLATION ENERGY-ABSORBI NG FORM REMOVAL/INSTALLATION SEAL PLATE REMOVAL/INSTALLATION FRONT FENDER PANEL REMOVAL/INSTALLATION SHROUD PANEL REMOVAL/INSTALLATION COWL PANEL REMOVAL/INSTALLATION REAR BUMPER REMOVAL/INSTALLATION REAR BUMPER DISASSEMBLY/ASSEMBLY REAR BUMPER REI NFORCEMENT REMOVAL/INSTALLATION

DOORS AND LIFTGATE

DOOR AND LI FTGATE LOCATION INDEX FRONT DOOR REMOVAL/INSTALLATION FRONT DOOR MODULE PANEL REMOVAL/INSTALLATION FRONT DOOR PAD REMOVAL/INSTALLATION FRONT DOOR CHECKER REMOVAL/INSTALLATION FRONT DOOR HI NGE REMOVAL/INSTALLATION REAR DOOR REMOVAL/INSTALLATION REAR DOOR MODULE PANEL REMOVAL/INSTALLATION REAR DOOR PAD REMOVAL/INSTALLATION REAR DOOR CHECKER REMOVAL/INSTALLATION REAR DOOR HI NGE REMOVAL/INSTALLATION REAR DOOR HOLE COVER REMOVAL REAR DOOR HOLE COVER INSTALLATION DOOR ADJUSTMENT

GLASS/WINDOWS/MIRRORS

GLASS/WINDOWS/MI RRORS LOCATION INDEX FRONT DOOR GLASS REMOVAL/INSTALLATION REAR DOOR GLASS REMOVAL/INSTALLATION REAR DOOR QUARTER GLASS REMOVAL/INSTALLATION WINDSHIELD REMOVAL WINDSHIELD INSTALLATION REAR WINDOW GLASS REMOVAL REAR WINDOW GLASS INSTALLATION FRONT POWER WINDOW REGULATOR REMOVAL/INSTALLATION REAR POWER WINDOW REGULATOR REMOVAL/INSTALLATION POWER WINDOW MOTOR REMOVAL/INSTALLATION POWER WINDOW MOTOR INSPECTION POWER WINDOW MAIN SWITCH REMOVAL/INSTALLATION POWER WINDOW MAIN SWITCH INSPECTION POWER WINDOW SUBSW I TCH REMOVAL/INSTALLATION POWER WINDOW SUBSW I TCH INSPECTION POWER OUTER MIRROR REMOVAL/INSTALLATION POWER OUTER MIRROR INSPECTION OUTER MIRROR GLASS REMOVAL OUTER MIRROR GLASS INSTALLATION OUTER MIRROR GLASS INSPECTION OUTER MIRROR GARNI SH REMOVAL/INSTALLATION POWER OUTER MIRROR SWITCH REMOVAL/INSTALLATION POWER OUTER MIRROR SWITCH INSPECTION FI LAMENT INSPECTION FI LAMENT REPAIR AUTO-DI MMI NG MIRROR REMOVAL AUTO-DI MMI NG MIRROR INSTALLATION AUTO-DI MMI NG MIRROR INSPECTION REARVI EW MIRROR REMOVAL REARVI EW MIRROR INSTALLATION MIRROR BASE REMOVAL MIRROR BASE INSTALLATION POWER WINDOW SYSTEM INITIALIZATION PROCEDURE PERSONALIZATION FEATURES SETTING PROCEDURE

SEATS

SEATS LOCATION INDEX FRONT SEAT REMOVAL/INSTALLATION FRONT SEAT BACK COMPONENT REMOVAL/INSTALLATION FRONT SEAT BACK TRIM REMOVAL/INSTALLATION FRONT SEAT CUSHION TRIM REMOVAL/INSTALLATION FRONT SEAT SLI DE ADJUSTER REMOVAL/INSTALLATION FRONT SEAT SIDE COVER REMOVAL/INSTALLATION REAR SEAT BACK REMOVAL/INSTALLATION REAR SEAT BACK FRAME REMOVAL/INSTALLATION REAR SEAT CUSHION REMOVAL/INSTALLATION REAR SEAT CUSHION TRIM REMOVAL/INSTALLATION REAR SIDE SEAT BACK REMOVAL/INSTALLATION FRONT TI LT MOTOR INSPECTION REAR TI LT MOTOR INSPECTION SLI DE MOTOR INSPECTION RECLI NER MOTOR INSPECTION POWER SEAT SWITCH REMOVAL/INSTALLATION POWER SEAT SWITCH INSPECTION POSITION MEMORY SWITCH REMOVAL/INSTALLATION POSITION MEMORY CONTROL MODULE INSPECTION POSITION MEMORY CONTROL MODULE REMOVAL/INSTALLATION POSITION MEMORY SWITCH INSPECTION SEAT WARMER SWITCH REMOVAL/INSTALLATION SEAT WARMER SWITCH INSPECTION SEAT WARMER MODULE REMOVAL/INSTALLATION SEAT WARMER MODULE INSPECTION SEAT WARMER UNIT REMOVAL/INSTALLATION SEAT WARMER UNIT INSPECTION

SECURITY AND LOCKS

SECURITY AND LOCKS LOCATION INDEX FRONT OUTER HANDLE REMOVAL/INSTALLATION REAR OUTER HANDLE REMOVAL/INSTALLATION INNER HANDLE REMOVAL/INSTALLATION DOOR LOCK SWITCH REMOVAL/INSTALLATION DOOR LOCK SWITCH INSPECTION HOOD LATCH AND RELEASE LEVER REMOVAL/INSTALLATION HOOD RELEASE CABLE REMOVAL/INSTALLATION HOOD LATCH SWITCH INSPECTION FUEL-FILLER LID OPENER CABLE REMOVAL/INSTALLATION FUEL-FILLER LID OPENER AND LEVER REMOVAL/INSTALLATION FRONT DOOR KEY CYLINDER REMOVAL/INSTALLATION FRONT DOOR KEY CYLINDER SWITCH INSPECTION FRONT DOOR LATCH AND LOCK ACTUATOR REMOVAL/INSTALLATION FRONT DOOR LATCH AND LOCK ACTUATOR INSPECTION FRONT DOOR LOCK ACTUATOR INSPECTION FRONT DOOR LATCH SWITCH INSPECTION DOOR LOCK-LINK SWITCH INSPECTION DOOR LOCK STRIKER REMOVAL/INSTALLATION REAR DOOR LATCH AND LOCK ACTUATOR REMOVAL/INSTALLATION REAR DOOR LATCH AND LOCK ACTUATOR INSPECTION REAR DOOR LATCH SWITCH INSPECTION REAR DOOR LOCK ACTUATOR INSPECTION TRUNK LID LATCH MANUAL RELEASE PROCEDURE TRUNK LID LATCH AND RELEASE ACTUATOR REMOVAL/INSTALLATION TRUNK LID LATCH AND RELEASE ACTUATOR INSPECTION TRUNK LID RELEASE ACTUATOR INSPECTION TRUNK LID LATCH SWITCH INSPECTION TRUNK LID LOCK STRIKER REMOVAL/INSTALLATION KEYLESS CONTROL MODULE REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS CONTROL MODULE INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS CONTROL MODULE CONFIGURATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] THEFT-DETERRENT SYSTEM READI NG FREEZE FRAME DATA THEFT-DETERRENT SYSTEM CLEARING FREEZE FRAME DATA KEYLESS RECEIVER REMOVAL/INSTALLATION KEYLESS RECEIVER INSPECTION [KEYLESS ENTRY SYSTEM] KEYLESS RECEIVER INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] TRANSMITTER BATTERY REPLACEMENT [KEYLESS ENTRY SYSTEM] TRANSMITTER ID CODE REGISTRATION [KEYLESS ENTRY SYSTEM] IMMOBILIZER SYSTEM-RELATED PARTS PROGRAMMI NG [KEYLESS ENTRY SYSTEM] IMMOBILIZER SYSTEM-RELATED PARTS PROGRAMMI NG [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] STEERING LOCK UNIT ID CODE REGISTRATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS ANTENNA REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS BEEPER REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEYLESS BEEPER INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] REQUEST SWITCH REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] TOUCH SENSOR REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] REQUEST SWITCH INSPECTION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] PERSONALIZATION FEATURES SETTING PROCEDURE COIL ANTENNA REMOVAL/INSTALLATION [KEYLESS ENTRY SYSTEM] ADVANCED KEY BATTERY REPLACEMENT [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] COIL ANTENNA REMOVAL/INSTALLATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] CLEARING ADVANCED KEY [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] ADVANCED KEY ID CODE REGISTRATION [ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] TRUNK LID OPENER SWITCH REMOVAL/INSTALLATION TRUNK LID OPENER SWITCH INSPECTION

SUNROOF

SUNROOF LOCATION INDEX DEFLECTOR REMOVAL/INSTALLATION GLASS PANEL REMOVAL/INSTALLATION GLASS PANEL ADJUSTMENT SUNROOF UNIT REMOVAL/INSTALLATION SUNROOF UNIT DISASSEMBLY/ASSEMBLY FRONT DRAIN HOSE REMOVAL FRONT DRAIN HOSE INSTALLATION REAR DRAIN HOSE REMOVAL REAR DRAIN HOSE INSTALLATION SUNROOF MOTOR REMOVAL/INSTALLATION SUNROOF MOTOR INSPECTION SUNROOF SWITCH REMOVAL/INSTALLATION SUNROOF SWITCH INSPECTION

EXTERIOR TRIM

EXTERIOR TRIM LOCATION INDEX COWL GRILLE REMOVAL/INSTALLATION SIDE STEP MOLDI NG REMOVAL SIDE STEP MOLDI NG INSTALLATION EXTRACTOR CHAMBER REMOVAL/INSTALLATION FRONT BELTLI NE MOLDI NG REMOVAL/INSTALLATION REAR BELTLI NE MOLDI NG REMOVAL/INSTALLATION ROOF MOLDI NG REMOVAL ROOF MOLDI NG INSTALLATION FRONT MUDGUARD REMOVAL/INSTALLATION REAR MUDGUARD REMOVAL/INSTALLATION REAR FI NI SHER REMOVAL/INSTALLATION REAR PILLAR GARNI SH REMOVAL/INSTALLATION AERODYNAMIC UNDER COVER NO.1 REMOVAL/INSTALLATION AERODYNAMIC UNDER COVER NO.2 REMOVAL/INSTALLATION FLOOR UNDER COVER REMOVAL/INSTALLATION SPLASH SHI ELD REMOVAL/INSTALLATION DOOR SASH FI LM REMOVAL DOOR SASH FI LM INSTALLATION FRONT SASH MOLDI NG REMOVAL FRONT SASH MOLDI NG INSTALLATION REAR SASH MOLDI NG REMOVAL REAR SASH MOLDI NG INSTALLATION

I NTERIOR TRIM

I NTERI OR TRIM LOCATION INDEX DASHBOARD REMOVAL/INSTALLATION SPEAKER GRILLE REMOVAL/INSTALLATION DASHBOARD DISASSEMBLY/ASSEMBLY COLUMN COVER REMOVAL/INSTALLATION CENTER PANEL UPPER REMOVAL/INSTALLATION CENTER PANEL LOWER REMOVAL/INSTALLATION LOWER PANEL REMOVAL/INSTALLATION SIDE PANEL REMOVAL/INSTALLATION METER HOOD REMOVAL/INSTALLATION GLOVE COMPARTMENT REMOVAL/INSTALLATION VENTI LATOR GRILLE REMOVAL/INSTALLATION KNEE BOLSTER REMOVAL/INSTALLATION DASHBOARD UNDER COVER REMOVAL/INSTALLATION UPPER PANEL REMOVAL/INSTALLATION SHIFT PANEL REMOVAL/INSTALLATION REAR CONSOLE REMOVAL/INSTALLATION REAR CONSOLE DISASSEMBLY/ASSEMBLY DECORATI ON PANEL REMOVAL/INSTALLATION A-PILLAR TRIM REMOVAL/INSTALLATION FRONT SIDE TRIM REMOVAL/INSTALLATION REAR PACKAGE TRIM REMOVAL/INSTALLATION B-PILLAR LOWER TRIM REMOVAL/INSTALLATION B-PILLAR UPPER TRIM REMOVAL/INSTALLATION C-PILLAR TRIM REMOVAL/INSTALLATION FRONT SCUFF PLATE REMOVAL/INSTALLATION REAR SCUFF PLATE REMOVAL/INSTALLATION INNER GARNI SH REMOVAL/INSTALLATION FUEL-FILLER LID OPENER BEZEL REMOVAL/INSTALLATION REAR DOOR TRIM DISASSEMBLY/ASSEMBLY TRUNK END TRIM REMOVAL/INSTALLATION TRUNK SIDE TRIM REMOVAL/INSTALLATION FRONT DOOR TRIM REMOVAL/INSTALLATION FRONT DOOR TRIM DISASSEMBLY/ASSEMBLY REAR DOOR TRIM REMOVAL/INSTALLATION TRUNK LID TRIM REMOVAL/INSTALLATION RECESS REMOVAL/INSTALLATION ASSIST HANDLE REMOVAL/INSTALLATION SUNVI SOR REMOVAL/INSTALLATION HEADLI NER REMOVAL/INSTALLATION FLOOR COVERI NG REMOVAL/INSTALLATION

LIGHTING SYSTEMS

LI GHTI NG SYSTEMS LOCATION INDEX DISCHARGE HEADLIGHT SERVICE WARNINGS FRONT COMBINATION LIGHT REMOVAL/INSTALLATION HEADLIGHT BULB REMOVAL/INSTALLATION HEADLIGHT AI MI NG DISCHARGE HEADLIGHT SYSTEM INSPECTION DISCHARGE HEADLIGHT CONTROL MODULE REMOVAL/INSTALLATION STEERING ANGLE SENSOR INSPECTION STEERING ANGLE SENSOR INITIALIZATION PROCEDURE PARKING/FRONT TURN LIGHT BULB REMOVAL/INSTALLATION FRONT SIDE MARKER LIGHT REMOVAL/INSTALLATION FRONT SIDE MARKER LIGHT BULB REMOVAL/INSTALLATION FRONT FOG LIGHT REMOVAL/INSTALLATION FRONT FOG LIGHT BULB REMOVAL/INSTALLATION FRONT FOG LIGHT AI MI NG SIDE TURN LIGHT REMOVAL/INSTALLATION SIDE TURN LIGHT INSPECTION REAR COMBINATION LIGHT REMOVAL/INSTALLATION REAR TURN LIGHT BULB REMOVAL/INSTALLATION BRAKE/TAILLIGHT BULB REMOVAL/INSTALLATION I NBOARD LIGHT REMOVAL/INSTALLATION I NBOARD LIGHT BULB REMOVAL/INSTALLATION HIGH-MOUNT BRAKE LIGHT REMOVAL/INSTALLATION LI CENSE PLATE LIGHT REMOVAL/INSTALLATION LI CENSE PLATE LIGHT BULB REMOVAL/INSTALLATION BACK-UP LIGHT SWITCH INSPECTION COMBINATION SWITCH REMOVAL/INSTALLATION COMBINATION SWITCH DISASSEMBLY/ASSEMBLY LIGHT SWITCH REMOVAL/INSTALLATION LIGHT SWITCH INSPECTION FRONT FOG LIGHT SWITCH INSPECTION HAZARD WARNING SWITCH REMOVAL/INSTALLATION HAZARD WARNING SWITCH INSPECTION HEADLIGHT LEVELI NG SWITCH REMOVAL/INSTALLATION HEADLIGHT LEVELI NG SWITCH INSPECTION AUTO LIGHT-OFF SYSTEM WIRING DIAGRAM AUTO LIGHT-OFF CONTROL MODULE REMOVAL/INSTALLATION AUTO LIGHT-OFF CONTROL MODULE INSPECTION DRL AND AUTO LIGHT SYSTEM WIRING DIAGRAM AUTO LIGHT/WIPER CONTROL MODULE REMOVAL/INSTALLATION AUTO LIGHT/WIPER CONTROL MODULE INSPECTION AUTO LIGHT/WIPER CONTROL MODULE CONFIGURATION LI GHTI NG SYSTEM PERSONALIZATION FEATURES SETTING PROCEDURE MAP LIGHT REMOVAL/INSTALLATION MAP LIGHT INSPECTION I NTERI OR LIGHT REMOVAL/INSTALLATION I NTERI OR LIGHT BULB REMOVAL/INSTALLATION TRUNK COMPARTMENT LIGHT BULB REMOVAL/INSTALLATION COURTESY LIGHT BULB REMOVAL/INSTALLATION IGNITION KEY ILLUMINATION REMOVAL/INSTALLATION GLOVE COMPARTMENT LIGHT BULB REMOVAL/INSTALLATION VANI TY MIRROR ILLUMINATION INSPECTION VANI TY MIRROR ILLUMINATION BULB REMOVAL/INSTALLATION I NDI RECT ILLUMINATION REMOVAL/INSTALLATION GROUND ILLUMINATION LIGHT REMOVAL/INSTALLATION

WIPER/WASHER SYSTEM

WIPER/WASHER SYSTEM LOCATION INDEX WINDSHIELD WIPER ARM AND BLADE REMOVAL/INSTALLATION WINDSHIELD WIPER ARM AND BLADE ADJUSTMENT WINDSHIELD WIPER MOTOR REMOVAL/INSTALLATION WINDSHIELD WIPER MOTOR DISASSEMBLY/ASSEMBLY WINDSHIELD WIPER MOTOR INSPECTION WASHER TANK REMOVAL/INSTALLATION WINDSHIELD WASHER MOTOR REMOVAL/INSTALLATION WINDSHIELD WASHER MOTOR INSPECTION WINDSHIELD WASHER NOZZLE REMOVAL/INSTALLATION WINDSHIELD WASHER HOSE REMOVAL/INSTALLATION WASHER FLUID-LEVEL SENSOR REMOVAL/INSTALLATION WASHER FLUID-LEVEL SENSOR INSPECTION WIPER AND WASHER SWITCH REMOVAL/INSTALLATION WINDSHIELD WIPER AND WASHER SWITCH INSPECTION AUTO LIGHT/WIPER CONTROL MODULE REMOVAL/INSTALLATION AUTO LIGHT/WIPER CONTROL MODULE INSPECTION RAIN SENSOR REMOVAL/INSTALLATION RAIN SENSOR INITIAL SETTING

ENTERTAINMENT

ENTERTAINMENT LOCATION INDEX AUDIO UNIT REMOVAL/INSTALLATION ENTERTAINMENT PERSONALIZATION FEATURES SETTING PROCEDURE CAR-NAVIGATION UNIT REMOVAL/INSTALLATION AUDIO AMPLIFIER REMOVAL/INSTALLATION FRONT DOOR SPEAKER REMOVAL/INSTALLATION FRONT DOOR SPEAKER INSPECTION REAR DOOR SPEAKER REMOVAL/INSTALLATION REAR DOOR SPEAKER INSPECTION FRONT CENTER SPEAKER REMOVAL/INSTALLATION FRONT CENTER SPEAKER INSPECTION REAR CENTER SPEAKER REMOVAL/INSTALLATION REAR CENTER SPEAKER INSPECTION REAR SPEAKER REMOVAL/INSTALLATION REAR SPEAKER INSPECTION TW EETER REMOVAL/INSTALLATION TW EETER INSPECTION AudioPilot® 2 MICROPHONE REMOVAL/INSTALLATION SIRIUS SATELLITE RADIO ANTENNA REMOVAL/INSTALLATION SIRIUS SATELLITE RADIO ANTENNA INSPECTION GLASS ANTENNA INSPECTION ANTENNA AMPLIFIER REMOVAL/INSTALLATION ANTENNA AMPLIFIER INSPECTION SIRIUS SATELLITE RADIO UNIT REMOVAL/INSTALLATION CONDENSER REMOVAL/INSTALLATION ANTENNA FEEDER LOCATION ANTENNA FEEDER NO.1 REMOVAL/INSTALLATION ANTENNA FEEDER NO.1 INSPECTION ANTENNA FEEDER NO.2 REMOVAL/INSTALLATION ANTENNA FEEDER NO.2 INSPECTION ANTENNA FEEDER NO.3 REMOVAL/INSTALLATION ANTENNA FEEDER NO.3 INSPECTION SIRIUS SATELLITE RADIO ANTENNA FEEDER REMOVAL/INSTALLATION SIRIUS SATELLITE RADIO ANTENNA FEEDER INSPECTION GPS ANTENNA REMOVAL/INSTALLATION GPS ANTENNA FEEDER REMOVAL/INSTALLATION GPS ANTENNA FEEDER INSPECTION STEERING SWITCH REMOVAL/INSTALLATION STEERING SWITCH INSPECTION MICROPHONE REMOVAL/INSTALLATION REAR MOUNT CAMERA REMOVAL/INSTALLATION Bluetooth UNIT REMOVAL/INSTALLATION ACCESSORY SOCKET REMOVAL/INSTALLATION ACCESSORY SOCKET INSPECTION AUXI LI ARY JACK REMOVAL/INSTALLATION AUXI LI ARY JACK INSPECTION

POWER SYSTEMS

POWER SYSTEM LOCATION INDEX [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] POWER SYSTEM LOCATION INDEX [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] FUSE SERVICE CAUTIONS MAIN FUSE REMOVAL/INSTALLATION IGNITION SWITCH REMOVAL/INSTALLATION [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] IGNITION SWITCH INSPECTION [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEY REMI NDER SWITCH REMOVAL/INSTALLATION [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] KEY REMI NDER SWITCH INSPECTION [WITHOUT ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] STEERING LOCK UNIT INSPECTION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] PUSH BUTTON START REMOVAL/INSTALLATION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] PUSH BUTTON START INSPECTION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] RELAY BLOCK REMOVAL/INSTALLATION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] RELAY BLOCK INSPECTION [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] POWER SYSTEMS PERSONALIZATION FEATURES SETTING PROCEDURE FORCED IGNITION ON [WITH ADVANCED KEYLESS ENTRY AND PUSH BUTTON START SYSTEM] RELAY LOCATION RELAY INSPECTION

INSTRUMENTATION/DRIVER I NFO.

INSTRUMENTATION/DRIVER I NFO. LOCATION INDEX INSTRUMENT CLUSTER REMOVAL/INSTALLATION INSTRUMENT CLUSTER DISASSEMBLY/ASSEMBLY INSTRUMENT CLUSTER INSPECTION INSTRUMENT CLUSTER CONFIGURATION INSTRUMENTATION/DRIVER I NFO. PERSONALIZATION FEATURES SETTING PROCEDURE I NFO SWITCH REMOVAL/INSTALLATION I NFO SWITCH INSPECTION FUEL GAUGE SENDER UNIT REMOVAL/INSTALLATION FUEL GAUGE SENDER UNIT INSPECTION OIL PRESSURE SWITCH INSPECTION HORN REMOVAL/INSTALLATION INFORMATION DISPLAY REMOVAL/INSTALLATION INFORMATION DISPLAY I NPUT/OUTPUT CHECK MODE BLIND SPOT MONITORING (BSM) CONTROL MODULE REMOVAL/INSTALLATION BLIND SPOT MONITORING (BSM) CONTROL MODULE INSPECTION BLIND SPOT MONITORING (BSM) BRACKET REMOVAL/INSTALLATION BLIND SPOT MONITORING (BSM) RADAR TEST BLIND SPOT MONITORING (BSM) OFF SWITCH REMOVAL/INSTALLATION BLIND SPOT MONITORING (BSM) OFF SWITCH INSPECTION BLIND SPOT MONITORING (BSM) INDICATOR LIGHT REMOVAL/INSTALLATION BLIND SPOT MONITORING (BSM) INDICATOR LIGHT INSPECTION

CONTROL SYSTEM

CONTROL SYSTEM LOCATION INDEX BODY CONTROL MODULE (BCM) REMOVAL/INSTALLATION BODY CONTROL MODULE (BCM) INSPECTION BODY CONTROL MODULE (BCM) CONFIGURATION CONTROL SYSTEM PERSONALIZATION FEATURES SETTING PROCEDURE

TECHNICAL DATA

BODY AND ACCESSORI ES TECHNICAL DATA

MAINTENANCE/SERVICE TOOLS

BODY AND ACCESSORI ES SST